|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
07-13-2011, 11:46 AM | #21 |
Gone Wild
Join Date: Jul 2008
Location: Reddick IL
Posts: 11,220
|
Re: My G2 dosent like rocks
No loctite, we touch the stub with a little never seize and put
the clutch on and spin it on the shaft, remove and wipe the shaft off. that leaves a little in the clutch making it easy to remove in the future. We hard launch 200+ HP sleds with know problem. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-13-2011, 02:28 PM | #22 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,445
|
Re: My G2 dosent like rocks
The primary clutch on the engine is a taper fit like snowmobiles are. It should be clean and smooth, it will hold anything that engine on a 100hp nitrous kit would put out. If it is damaged the clutch could wobble and be off balance. Make sure it is clean in the clutch and the crankshaft. You can put a very thin layer of antiseize/etc like posted above, but not much, don't use grease. I like to use wd40/etc and wipe off so its just a little wet with it, mostly so it can't rust/corrode as much.
I'd guess someone used a big impact and just hammered it down too far. |
07-13-2011, 05:09 PM | #23 |
Not Yet Wild
Join Date: Oct 2010
Posts: 63
|
Re: My G2 dosent like rocks
ok thanks for the info guys, thats what i wanted to know
hopfuly it will hold ok with the new bolt |
07-13-2011, 07:53 PM | #24 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,445
|
Re: My G2 dosent like rocks
You might need to run a tap in the threads, and verify they are ok. Mine seemed to go into the threads deeper than that (G9 yami).
|
07-13-2011, 11:06 PM | #25 |
Not Yet Wild
Join Date: Oct 2010
Posts: 63
|
Re: My G2 dosent like rocks
the striped bolt had two washers on it, im guessing because they knew it was striped and it wouldent go far enough in to hold lol
my friend has a tap kit, will check to make sure the threads are fine to be sure more damage isent done |
07-13-2011, 11:18 PM | #26 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: My G2 dosent like rocks
Sorry Coil, I don't know what I was thinking, when I asked if that bolt was out of the secondary! Brain just wasn't straight!!
|
07-14-2011, 11:25 AM | #27 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,445
|
Re: My G2 dosent like rocks
|
07-14-2011, 01:49 PM | #28 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: My G2 dosent like rocks
Ya, but its dry, so they say!
|
07-14-2011, 06:26 PM | #29 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,445
|
Re: My G2 dosent like rocks
Well then, maybe dehydration!
|
07-14-2011, 08:15 PM | #30 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: My G2 dosent like rocks
Actually not, my brain does that quite often!! More so with age!
Coil, you get that thing runnin? |
|
|
Similar Threads | ||||
Thread | Forum | |||
Plum Quick Assassin ROCKS! | Electric EZGO | |||
Exaust Idea That Rocks | Members Rides | |||
89 marathon, starter only rocks engine | Gas EZGO |