|
|
|||||||
| Electric Club Car Electric DS, and Precedent golf cars |
  |
|
|
Thread Tools | Display Modes |
10-14-2019, 10:28 AM
|
#1 |
|
Not Yet Wild
Join Date: Oct 2019
Posts: 3
|
Power Drive 2 Charger Relay
Our Club Car cart was moved while still plugged in. The AC power in terminals came off both the breaker and relay terminals. Got everything re connected except the bottom 2 terminals on the relay. One is for the breaker and one for the primary coil but the diagram I have isn’t clear on which wire goes where. Any advice would be much appreciated.
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
10-14-2019, 11:30 AM
|
#2 |
|
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Power Drive 2 Charger Relay
The terminals should be marked on the relay for AC or Coil side.
Was the cart driven with the charger plugged in or was it pushed? With a properly functioning charging system and OBC the cart should not be drive-able while the charger is plugged in. |
|
|
|
|
10-14-2019, 11:45 AM
|
#3 |
|
Gone Wild
 Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Power Drive 2 Charger Relay
If the replacement relay only has two 1/4" terminals (SPST) then use either one for either wire.
If the relay has three 1/4" terminals (SPDT) then plug the breaker wire on the NO terminal and the transformer wire to the COM terminal. |
|
|
|
|
10-14-2019, 12:17 PM
|
#4 |
|
Not Yet Wild
Join Date: Oct 2019
Posts: 3
|
Re: Power Drive 2 Charger Relay
The charger was not plugged in to the cart it was just rest on the cart floor but the Ac cord caught on something and disconnected the wires inside the charger.
|
|
|
|
|
10-14-2019, 12:19 PM
|
#5 |
|
Not Yet Wild
Join Date: Oct 2019
Posts: 3
|
Re: Power Drive 2 Charger Relay
The relay has 4 terminals but 2 were not disconnected. The two that came off are COM and NO. I assume the wire from the breaker should go to COM (?)
|
|
|
|
|
10-14-2019, 12:38 PM
|
#6 |
|
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Power Drive 2 Charger Relay
That is a SPST relay. It can go in either terminal, COM is fine
By the way the coil terminals are smaller, they are 3/16". |
|
|
|
|
|
||||||
| Thread Tools | |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Power Drive Charger vs Power Drive 3 Charger | Electric Club Car | |||
| Power Drive 3 Charger | Electric Club Car | |||
| power drive 2 charger | Electric Club Car | |||
| Bad Power drive 2 charger Need Help | Electric Club Car | |||
| Power Drive Charger won't come on | Electric Club Car | |||
Linear Mode
