|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
07-16-2014, 12:31 PM | #1 |
Not Yet Wild
Join Date: Jul 2014
Posts: 7
|
2008 Club car Precedent IQ cuts off
I have a 08 CC Precedent 48v (4-12v) system. I recently had the speed sensor fail and replaced it, worked good for a few days. Today after using the cart for 1/2 hour the power cut out. It resets and will try to move but cuts out again immediately. Fully charged the batteries and still same problem press pedel slightly cart tries to move then it just looses power. Any suggestions ? Thanks
2008 CC Precedent 48v IQ Regen Batteries: Terminals clean, 14.4-14.7 volts each, 51.4 across the pack. Shows good (500 amps) under load test drops to 10.5 - 10.9v under load on each battery. Noticed with cart key off and run/tow set to tow battery sparked when connecting last cable ? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-17-2014, 09:21 AM | #2 |
Not Yet Wild
Join Date: Jul 2014
Posts: 7
|
Re: 2008 Club car Precedent IQ cuts off
Update: Today I tried the cart again. Checked wiring connections etc. I got the cart to move on a flat surface about 300 ft by barely pushing the pedal. Once I got it in the garage I tried to increase pedal and it looses power. Take your foot off pedal and your hear the "click" and the cart tries to move but does not. Seems something is tripping when a load is put on it or speed increases. The motor has the "speed magnet" installed and the "speed sensor test" does still cause the beep when pushed. I'm clueless where to start
|
07-17-2014, 09:57 AM | #3 | |
Getting Wild
Join Date: Jun 2014
Location: Alabama
Posts: 76
|
Re: 2008 Club car Precedent IQ cuts off
Quote:
|
|
07-17-2014, 09:57 AM | #4 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2008 Club car Precedent IQ cuts off
What's the serial number?
|
07-19-2014, 09:51 AM | #5 |
Not Yet Wild
Join Date: Jul 2014
Posts: 7
|
Re: 2008 Club car Precedent IQ cuts off
Pq083 -xxxxx
|
07-19-2014, 03:40 PM | #6 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2008 Club car Precedent IQ cuts off
It sounds like a potential solenoid failure based on what you've described. You say you try to go but it won't, sometimes. But sometimes it will. That's quite possibly a bad solenoid for sure. Also, you say when you're driving it'll die out. The IQ system is designed to come to a stop if the solenoid drops out. I'd try replacing the solenoid if you don't have access to a scanner to see exactly what's going on.
|
07-19-2014, 05:07 PM | #7 |
Not Yet Wild
Join Date: Jul 2014
Posts: 7
|
Re: 2008 Club car Precedent IQ cuts off
If it sits for an hour you can creep along at 1 mph (or less). Try to increase speed and it cuts out. You can immediately repress pedal and it will power on again but try to go forward at any speed and it cuts out without moving. Let it sit for an hour and you can creep again until you increase speed.
|
07-19-2014, 08:42 PM | #8 | |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2008 Club car Precedent IQ cuts off
Quote:
|
|
07-20-2014, 05:52 AM | #9 |
Not Yet Wild
Join Date: Jul 2014
Posts: 7
|
Re: 2008 Club car Precedent IQ cuts off
51.4 across the pack. Shows good (500 amps) under load test drops to 10.5 - 10.9v under load on each battery
|
07-20-2014, 11:25 AM | #10 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2008 Club car Precedent IQ cuts off
Never seen a cart with these symptoms. I recommend taking it to a dealer and having it scanned
|
Tags |
club car, club car precedent, electric ds, precedent, precedent golf cars |
|
|
Similar Threads | ||||
Thread | Forum | |||
2008 club car precedent wont go over 13 mph | Electric Club Car | |||
Please help 2008 club car precedent only goes 8mph | Electric Club Car | |||
2008 Club Car Precedent vs. 2008 ezgo pds | Electric Club Car | |||
2008 Club Car precedent vs. 2008 ezgo pds | Electric EZGO | |||
value of 2008 club car precedent | Electric Club Car |