|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
01-24-2016, 11:38 AM | #1 |
Not Yet Wild
Join Date: Nov 2014
Posts: 4
|
2002 CC with Alltrax DCX 500 fails to slow
The cart SN is AQ0224-155876 and has a D&D Motor. It will run OK for a few minutes then fail to barely able to move. The alltrax has a harness converter board to fit the cart harness. The batteries are good and the charger works. I used my controller pro software and the controller is set right but the throttle position will go from 100 to 13 %. I replaced the MCOR and it ran about 15 minutes normally and then went to hardly moving and no power. So far I can't find a harness issue. I don't believe the Alltrax uses a speed sensor all though the motor has one. Help!
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-24-2016, 11:57 AM | #2 |
Gone Wild
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
|
Re: 2002 CC with Alltrax DCX 500 fails to slow
The throttle should go from 0% to 100%. Check setting and make sure Club Car 5k to 0 is selected. Is this a new install or has it been working? Don't forget to click SET afterwards. Some of these carts have resistors soldered inline. You might have to do a search to see if yours is one of them. And no it doesn't use the speed sensor but you can plug it in anyway.
|
01-24-2016, 12:17 PM | #3 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,356
|
Re: 2002 CC with Alltrax DCX 500 fails to slow
Those converter boards had some issues late in production. Call Alltrax tech support and ask about the possibility of a converter board failure.
|
01-24-2016, 02:00 PM | #4 |
Not Yet Wild
Join Date: Nov 2014
Posts: 4
|
Re: 2002 CC with Alltrax DCX 500 fails to slow
The controller is set on CC 5K-0 3 wire on throttle. I measured it at the alltrax board on cart harness and it is getting the correct readings yet the controller pin side of the board are not. I will check on board from Alltrax- thanks
|
01-24-2016, 04:27 PM | #5 |
Gone Wild
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
|
Re: 2002 CC with Alltrax DCX 500 fails to slow
Just for grins I would be tempted to try the 0-5k setting to see if something is wired backwards.
|
Tags |
cc slow speed |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Slow 2002 CC DS | Electric Club Car | |||
2002 G16 is slow and won't rev up | Gas Yamaha | |||
Have 2002 series txt, switching from 32v-48v and alltrax 485 and f&r switch | Electric EZGO | |||
2002 club car and alltrax 4855 charge problems | Electric Club Car | |||
2002 36v cc new batteries but very slow | Electric Club Car |