|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
05-21-2017, 08:07 AM | #1 |
Not Yet Wild
Join Date: Jul 2016
Posts: 22
|
1996 Club Car New Batteries but still will not start
First electric cart. Need some help troubleshooting 48 volt. I put new batteries in last night cart did not move and charged over night and still no movement. I do not here any clicking from the solenoids and I am guess that may be my problem. The cart had been sitting for a while. The first couple time I depressed the pedal I could here a slight spinning noise of some sort but seemed to die off after a few seconds. Cart does roll so I can believe the motor is not locked up. Please any information would be helpful. Diagrams or parts lists would be great. Thanks again Serial number A963-492677
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-31-2017, 08:22 AM | #2 |
Not Yet Wild
Join Date: Jul 2016
Posts: 22
|
Re: 1996 Club Car New Batteries but still will not start
Was able to replace the first solenoid and was able to here the click with the key on. Now my only problem is that it seems to be running at half speed?? When I press the pedal it take 2-3seconds before it takes off, on the flat ground it seems to get up to speed, although it will barely go up any hill. Reverse seems very slow as well. need help! Thanks
|
05-31-2017, 08:54 AM | #3 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 1996 Club Car New Batteries but still will not start
The dynamic brake solenoid, the one with the resistor coil, is not closing.
You can either replace it, or jsut remove it from the circuit. To remove it: Connect both white cables to the same solenoid big post.You do not have to disconnect the other wires from the Solenoid. |
08-02-2017, 03:50 PM | #4 |
Not Yet Wild
Join Date: Jul 2016
Posts: 22
|
Re: 1996 Club Car New Batteries but still will not start
End result was the yellow wire coming from the pedal pot box, had some corrosion on it and I was able to cut it out and re-splice and the speed came back to the cart. amazing such little thing cause such a big problem.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
1996 club car won't start. | Gas Club Car | |||
1996 Club Car wont start after initial use. | Gas Club Car | |||
1996 Club Car won't start | Gas Club Car | |||
1996 Club Cart Wont Start | Gas Club Car | |||
1996 Club Car 48v will not start up | Electric Club Car |