|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-30-2021, 03:50 PM | #1 |
Not Yet Wild
Join Date: Jun 2010
Posts: 36
|
DS won't reach above 7 mph
06 Ds, 400a Alltrax, DD
Cart would routinely cruise 22-24 mph, after moderate length ride, now will accelerate normal and then top out around 7. From what I've researched here, speed sensor? Throttle sensor or mcor. Haven't hooked up USB to allltrax yet, has a steady green light. Motor doesn't get hot, no burning, volts under load didip to around 49v. Haven't gotten to speak to DD yet either. The light will flash amber when driven, which according to manual says throttle is wide open but controller is in current limit. What would cause the controller to limit itself |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-30-2021, 04:44 PM | #2 |
Gone Wild
Join Date: May 2021
Posts: 289
|
Re: DS won't reach above 7 mph
I cannot be certain but when you are full throttle but the cart is in limp mode its usually a speed sensor. I cannot say for sure as I do not have the experience with alltrax as some of the great people this forum but that symptom is usually a speed sensor issue. Check the magnet also. Is it cracked?
|
08-30-2021, 04:59 PM | #3 |
Not Yet Wild
Join Date: Jun 2010
Posts: 36
|
Re: DS won't reach above 7 mph
Its been 4 plus years since I was under it, is speed sensor the piece with pigtails on motor end? Seems like the amount of stuff I got working is 10 percent of all my stuff lately
|
08-30-2021, 05:10 PM | #4 |
Gone Wild
Join Date: May 2021
Posts: 289
|
Re: DS won't reach above 7 mph
Yep. End of the motor. Has 3 wires. You can take the speed sensor off and inspect the magnet for any damage or cracks. The magnet is right behind the speed sensor.
|
08-30-2021, 05:15 PM | #5 |
Gone Wild
Join Date: May 2021
Posts: 289
|
Re: DS won't reach above 7 mph
Read this thread. Explains how to do a roll test of the speed sensor.
https://www.buggiesgonewild.com/showthread.php?t=68248 |
08-30-2021, 06:28 PM | #6 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: DS won't reach above 7 mph
You can disable the speed limit in the controller to test the speed sensor.
Likely the speed sensor is bad, but check the magnet as well for any cracks. |
|
|
Similar Threads | ||||
Thread | Forum | |||
New batteries never reach full charge | Electric EZGO | |||
Can't Reach the Steering Wheel | Electric Club Car | |||
Cart wont reach top speed | Gas EZGO | |||
G14A - Intake leak, not able to reach full speed | Gas Yamaha |