|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
07-21-2016, 12:57 PM | #1 |
Not Yet Wild
Join Date: Feb 2013
Location: New Jersey
Posts: 19
|
Input shaft Removal
2005 EZ GO TXT Series cart 36 volts.
Input shaft leaking at bearing seal Can the Input shaft on my 2005 ez go txt series cart with Dana differential be removed without droping the axel and removing the entire gear set (intermediate and limited slip gears). I have a slight leak somewhere on the sealed bearing in the input gear. The Input gear is fitted tight In the housing and cannot be pulled by hand. I do not want to damage splined input shaft. Banging on the transfer case at the opposite side does not knock it loose. Any suggestions? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-21-2016, 01:32 PM | #2 |
Not Yet Wild
Join Date: Dec 2011
Location: Oakwood GA
Posts: 9
|
Re: Input shaft Removal
I carefully clamp a vise grip on the shaft and tap the vise grip with a soft hammer. they always come out easily.
|
07-21-2016, 02:50 PM | #3 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: Input shaft Removal
yes, note the C clip
|
07-21-2016, 07:09 PM | #4 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: Input shaft Removal
AS mentioned, you can go in from the top and only have to remove the motor to pull the input gear assembly.
After removing C-Clip, I wrapped a piece of an old leather belt around the splines to protect them, clamped on some vice grips, tapped a few times with a small hammer and it came out. Other than removing the motor, the most difficult part for me was getting the C-clip back in when I reinstalled the input gear assembly. |
07-27-2016, 06:35 AM | #5 |
Not Yet Wild
Join Date: Feb 2013
Location: New Jersey
Posts: 19
|
Re: Input shaft Removal
Thanks guys all of your input helped and it was a snap to get done once again thank you
|
Tags |
axel, dana differential, input gear |
|
|
Similar Threads | ||||
Thread | Forum | |||
DS Input shaft removal? | Electric Club Car | |||
differential input shaft removal | Electric EZGO | |||
input shaft removal G16 gas | Gas Yamaha | |||
1992 ez-go input shaft removal | Gas EZGO |