|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
11-02-2014, 02:54 PM | #11 |
Not Yet Wild
Join Date: Nov 2014
Posts: 1
|
Re: Rxv wheel shaking
Well the tie rod is cheap. If he is not sure then you might need a new mechanic. Do your tie rod checks/hub checks first. If those are tight then it is the steering box
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-02-2014, 03:26 PM | #12 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Rxv wheel shaking
Well, the rack housing has a bushing near each end to support the rack gear (i have seen these bushings worn/damaged, esp. on lifted carts), the tie-rods screw & lock into the ends of the rack gear. These bushings can be checked by applying up-down pressure on the tie-rods, any up-down movement is bad. There is no provisions for routine greasing/maintaining these bushings besides removing bellows boots and trying to force grease in the bushings (usually makes a big mess, with little grease actually getting inside). I do not believe they sell any of the internal rack parts individually, only a whole rack assembly. The tie-rods have been pretty good IMO, with only a little loosening in the sockets, but not "sloppy" (again, no provisions for grease/maintainence). What they are telling you seems reasonable (but they did a poor job of explaning it).
|
11-02-2014, 03:53 PM | #13 |
Gone Wild
Join Date: Aug 2014
Location: Duncan Corners
Posts: 905
|
Re: Rxv wheel shaking
Might check bushings on A frame.
Bushings to upper and lower a frame wear and cause sloppy suspension. raise cart & place jackstands under FRAME. Grasp front wheel & move around. You should SEE any wear or movement. Have seen outer tie rod ends go bad-- very little problems w/rack and pinion (mostly related to abuse). Good luck !! |
11-02-2014, 07:45 PM | #14 |
Gone Wild
Join Date: Dec 2013
Location: Montreal Qc
Posts: 682
|
Re: Rxv wheel shaking
|
11-02-2014, 08:15 PM | #15 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Rxv wheel shaking
Please re-read description about bushings in steering rack housing. There is actually one bearing in the steering rack, it goes to the steering wheel shaft, NOT the tie rods. Replace the bearing if you want, the bushings at the ends of the rack housing will still be bad.
|
11-03-2014, 08:13 AM | #16 |
Gone Wild
Join Date: Dec 2013
Location: Montreal Qc
Posts: 682
|
Re: Rxv wheel shaking
Ok,, i think i will bring the steering box to the dealer because i have to much doubt.. Thank for your help....
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Top and Windshield shaking | Electric Club Car | |||
91 gas club car shaking | Gas Club Car | |||
89 DS Bouncing and Shaking | Gas Club Car | |||
club car is shaking | Electric Club Car | |||
g9 shaking | Gas Yamaha |