|
|
|||||||
| Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
  |
|
|
Thread Tools | Display Modes |
04-29-2021, 05:01 PM
|
#1 |
|
Not Yet Wild
Join Date: Apr 2021
Posts: 1
|
1996 G16 start issues
I have a '96 gas G16. Was working great last fall. This Spring took out of storage, charged battery. Cart would not start. Checked all the switches(ignition, accelerator speed switch, all are good.
When I jump the solenoid it starts. I even swapped out solenoid because I thought it may be bad. Main fuse is good. Wont start in forward, neutral or reverse. Just a dead pedal. All connectors on wiring harness look good. Appreciate any ideas as to where to perhaps check? Thanks in advanced |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
04-30-2021, 06:14 AM
|
#2 |
|
Not Yet Wild
Join Date: Aug 2020
Location: delavan,Wi
Posts: 8
|
Re: 1996 G16 start issues
do you know if the brushes in the starter have been done?
|
|
|
|
|
04-30-2021, 07:07 AM
|
#3 |
|
Gone Wild
Join Date: Nov 2015
Posts: 460
|
Re: 1996 G16 start issues
Be sure small black wire (that goes to ground at solenoid) is good.
|
|
|
|
|
04-30-2021, 07:17 AM
|
#4 |
|
Gone Wild
 Join Date: Sep 2010
Location: Florida
Posts: 1,895
|
Re: 1996 G16 start issues
If it starts by jumping solenoid starter brushes aren't issue...however I agree there is a small black bullet connector coming off of the main negative cable coming off of the battery if you follow it back...make sure that is plugged in and making good connection...you can also try just running a jumper wire from main negative to small black wire post on solenoid and try again..
|
|
|
|
|
04-30-2021, 12:44 PM
|
#5 |
|
Not Yet Wild
Join Date: Jan 2021
Posts: 5
|
Re: 1996 G16 start issues
Me and our neighbor both had that same problem this spring. His a Club Car and Mine a Yamaha G16. Cylinder was filled with gas. Float in Carb was stuck open. Removed carb and cleaned out. Changed out oil ,the crankcase partially filled with gas. New Carb is on the way. Randy
|
|
|
|
|
05-01-2021, 06:13 AM
|
#6 | |
|
maintaining a low profile
Join Date: Oct 2009
Location: SW Virginia USA
Posts: 6,316
|
Re: 1996 G16 start issues
Quote:
|
|
|
|
|
|
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| 1996 Club Car DS 48v won't start | Electric Club Car | |||
| 1996 48v ds speed issues | Electric Club Car | |||
| 1996 G16 No Start after oil overfill | Gas Yamaha | |||
| 1996 TXT won't start... | Gas EZGO | |||
| 1996 Club Car 48v will not start up | Electric Club Car | |||
Linear Mode
