|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
12-05-2011, 04:03 PM | #1 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
1999 Non-DCS will run jacked up only
Have a 1999 NON-DCS electric 36 volt cart. Batteries are fine. Cart would only move in reverse. Checked hubs, replaced controller, replaced rear motor. There is of course power to the solenoid and both microswitches are good on F/R switch. We have these parts in stock so not a biggie. Anyway, when the cart is jacked up in the rear, it will run in forward and reverse now. So we were very excited. Until it was put on the ground. The cart will only move in reverse and try to move in forward but will not. Any thoughts?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-05-2011, 04:19 PM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: 1999 Non-DCS will run jacked up only
Stripped hubs or bad batteries?
|
12-06-2011, 02:28 PM | #3 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
Re: 1999 Non-DCS will run jacked up only
The hubs have been checked as well as the batteries. going to send control box out for verification of repair.
|
12-06-2011, 02:33 PM | #4 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: 1999 Non-DCS will run jacked up only
How did you check your hubs?
How did you check your batteries? |
12-06-2011, 06:06 PM | #5 | |
48/400/Alltrax HS motor
Join Date: Jan 2007
Location: Liberty SC, Garden City SC
Posts: 6,190
|
Re: 1999 Non-DCS will run jacked up only
Quote:
|
|
12-07-2011, 08:36 AM | #6 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
Re: 1999 Non-DCS will run jacked up only
will double check this and get back to you.Thanks!
|
12-07-2011, 09:47 AM | #7 |
48/400/Alltrax HS motor
Join Date: Jan 2007
Location: Liberty SC, Garden City SC
Posts: 6,190
|
Re: 1999 Non-DCS will run jacked up only
I think you will find it's either the hubs are the batteries. I say hubs though!
|
01-11-2012, 12:15 PM | #8 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
Re: 1999 Non-DCS will run jacked up only
so i wanted to touch base and wrap up this doozie. After checking the wiring yet again!!!AAAHHH. It was discovered a wire from f/r switch to control box had very small short in wiring. Thus shorting out the control box too. Do you believe it! Goes to show even the most complex mind-boggling problem could always be something simple.DUH
|
|
|
Similar Threads | ||||
Thread | Forum | |||
1999 G16 won't go | Electric Yamaha | |||
1999 ez go will not run | Gas EZGO | |||
My 02 EZGO ST480 Worhorse-jacked up | Lifted Golf Carts |