lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric golf carts > Columbia ParCar


Post New Thread  Reply
 
Thread Tools Display Modes
Old 10-12-2015, 11:07 PM   #1
Charles James
Not Yet Wild
 
Join Date: Oct 2015
Posts: 1
Default Sevcon 3 flashes

Good evening I have a Columbia BC2L-48 currently code 3 I was driving along and after a few moments of jitters the unit stopped and would not run no power to attachments nothing. I checked and found two bad battery cables and just went ahead and replace all the short battery link cables. I powered up the unit and tested the lights and dump attachment all worked fine I jumped in and drove about twenty feet and the unit stopped again this time the controller was flashing 3 blinks. I also noticed the strobe light was not flashing but all the accessories work, just no travel I checked and it seems I am not getting power to the contactor or to the strobe but i need to know the sequence of operation for the contactor to receive power I checked all the fuses, looked for chaffed wiring tested batteries after a good charge. when does the contactor close? when the key is turned on, or key then directional engaged, or key direction, throttle? I only tested with key, directional no throttle. does anyone have a schematic for this unit? Thank You
Charles James is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 10-13-2015, 03:28 PM   #2
Tech Support
How Can I Help?
 
Tech Support's Avatar
 
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,308
Default Re: Sevcon 3 flashes

Contactor is powered by controller, but any faults will disable the contactor. (Accessories are independent of contactor and controller, wired to batteries direct usually).

3 flash indicates the armature circuit in the controller is sensing a problem. Could be brush problem in motor, armature short, or faulty controller.
Tech Support is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric golf carts > Columbia ParCar


Thread Tools
Display Modes


Similar Threads
Thread Forum
RXV charger 2 red flashes. Electric EZGO
Sevcon controller Columbia ParCar
Sevcon 633T45303 Columbia ParCar
sevcon DC/DC converter Golf Carts and Parts


All times are GMT -5. The time now is 04:55 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2023, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.