|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-10-2020, 07:27 PM | #1 |
Not Yet Wild
Join Date: Aug 2020
Posts: 18
|
Struggling with 2007 Ezgo
Hey,Everyone,
2007, Ezgo. 36 volt, PDS, battery pack at 36.4 Volts , New FNR switch, new H.D. solenoid, new Throttle sensor and micro switch. New battery cables. Curtis controler, sent out for 400amp upgrade. Repair place said controller was fine didnt see anything wrong with it. Then upgraded. Raise rear wheels , put in Forward and slowly step on pedal, solenoid clicks and wheels start moving. Get pedal about half way down and it's like solenoid releases and wheels stop moving. Put in reverse and step on pedal, wheels start moving and can push pedal all the way down to floor. Lower cart to ground and try to go , Forward and step on pedal and no go ,get to half pedal and click . Have tried another solenoid and same results. All connections are clean and tight. Any help would be Much appreciated. Thanks again.... Pepper64 |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-11-2020, 05:24 AM | #2 |
Gone Wild
Join Date: Feb 2016
Location: Upstate Western New York
Posts: 465
|
Re: Struggling with 2007 Ezgo
36.4 volts is barely 50% charged. If that is the voltage 12 hours after the charge cycle is finished, You have charger/battery problems. What are the individual voltages of each battery? What does the pack voltage drop to when you try to drive the cart?
|
09-11-2020, 07:03 AM | #3 |
Not Yet Wild
Join Date: Aug 2020
Posts: 18
|
Re: Struggling with 2007 Ezgo
Thanks for info, working a lot lately, I should have time this weekend to check each battery , i will also check volts when trying to drive . Thanks again , I will update info after checks.
Pepper64 |
08-14-2021, 08:09 AM | #4 |
Not Yet Wild
Join Date: Aug 2020
Posts: 18
|
Re: Struggling with 2007 Ezgo
Update, been working like crazy, turns out I had 3 bad batteries, replaced with new and added speed chip. Runs awesome
|
|
|
Similar Threads | ||||
Thread | Forum | |||
G2 Yamaha struggling up hills | Gas Yamaha | |||
struggling with the tie rods | Gas Yamaha | |||
Struggling uphill | Electric Club Car | |||
G22 gas struggling to get going | Gas Yamaha | |||
EZ-GO struggling up hills, possible preignition | Gas EZGO |