12-18-2009, 08:39 PM | #1 |
Not Yet Wild
Join Date: Dec 2009
Posts: 17
|
87 gas club car
OK....Let me try this again. Hope this is not the Introduction Forum as I am new. My 87 club car starts ok but it does not have much power. It smells like it is running rich but the plug is not black and I see no black smoke. The air filter is fine. When I push the throttle it only accelerates for the first half of the throttle travel. Thanks for any help. This is my first golf cart.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-18-2009, 08:45 PM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,410
|
Re: 87 gas club car
Hello amp077, lets first determine if the throttle peddle, cable. & linkage is working. With the air cleaner off and the seat removed.... the key removed.... push the gas peddle and look to see if in fact the throttle plate is opening ALL the way to WOT?
|
12-18-2009, 08:50 PM | #3 |
Not Yet Wild
Join Date: Dec 2009
Posts: 17
|
Re: 87 gas club car
Yes it is.
|
12-18-2009, 09:08 PM | #4 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,410
|
Re: 87 gas club car
I think we gotta eliminate the obvious..... Do you have access to a compression guage? .....what is the compression ?
Are the tires stock? |
12-18-2009, 09:17 PM | #5 |
Not Yet Wild
Join Date: Dec 2009
Posts: 17
|
Re: 87 gas club car
The tires are stock. Is this cart supposed to start and run in neutral? I'll check the compression.
|
12-18-2009, 09:51 PM | #6 |
Not Yet Wild
Join Date: Dec 2009
Posts: 17
|
Re: 87 gas club car
compression is almost 50psi.
|
12-18-2009, 09:54 PM | #7 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,410
|
Re: 87 gas club car
That is a problem....... very low compression.... Did you have the throttle wide open for the test and let it turn several revolutions?
|
12-18-2009, 09:59 PM | #8 |
Not Yet Wild
Join Date: Dec 2009
Posts: 17
|
Re: 87 gas club car
If I push the throttle the cart will try to move. It will only turn over in forward or reverse.
|
12-18-2009, 10:00 PM | #9 |
Not Yet Wild
Join Date: Dec 2009
Posts: 17
|
Re: 87 gas club car
Could a plugged exhaust cause this?
|
12-18-2009, 10:04 PM | #10 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,410
|
Re: 87 gas club car
Jack the cart up and redo the test. Anything below 150 is unacceptable.
|