|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-05-2015, 01:12 PM | #1 |
Not Yet Wild
Join Date: Aug 2012
Posts: 38
|
Precedent shutdown at full throttle. Excel
Hi all,
This one has been troubling me for a bit. From the beginning, Cart smoked its controller. You could smell the electrical burnt smell near it. Got a refurbished excel controller with speed 4 installed. Put it in and the cart started running again except if the throttle is all the way down the cart stopped accelerating and regen braking slows it down, back off on the throttle and it starts going again. Plugged in the IQDM P and watch the throttle position. Somewhere around 90 percent it drops to zero and gives you the above symptoms. I go for that as mcor issue and order replacement. No change. Searching around on here. I find a thread that TDawg answered on. The tps adaptor has failed. Ordered that, replaced, and still no change. Now I have come full circle to the controller, is it possible this is a programming issue with the rebuilt controller, or just a defect, and it thinks its going out of range? Or is there something else I should look for? Thanks for the help Rom |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-05-2015, 02:11 PM | #2 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Precedent shutdown at full throttle. Excel
Measure the actual voltage on the yellow MCOR wire in relation to pack negative (meter on 20v DC scale).
The last time the TPS to MCOR adapter was discussed, TahoeDawg said that both versions (IQ and Excel) had the same part number. I have no idea how the dealer can tell which ones have the resistors internally (Excel model) and which one don't (IQ model). The 451Ω resistors will change the throttle signal as seen by the controller from 0-5v to 0.35-4.65v, so if You don't have the resistors in yours, it will give you a throttle fault (out of range) if it goes to 5v. |
04-05-2015, 02:26 PM | #3 |
Not Yet Wild
Join Date: Aug 2012
Posts: 38
|
Ok I will be visiting the cart tomorrow. Will double check the readings. How would I go about correcting this if this is the fault?
|
04-05-2015, 02:39 PM | #4 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Precedent shutdown at full throttle. Excel
I'm following this thread to see how it develops.
|
04-05-2015, 02:47 PM | #5 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Precedent shutdown at full throttle. Excel
You can disconnect the 16-pin connector from the controller and the 3-pin connector from the MCOR.
Measure the resistance on each of the wires from the controller to the MCOR. You should see approximately 451Ω, if you measure 0Ω instead, you have the wrong TPS adapter for an Excel cart. |
04-05-2015, 02:47 PM | #6 |
Gone Wild
Join Date: Jan 2014
Location: Lafayette, Louisiana
Posts: 1,677
|
Re: Precedent shutdown at full throttle. Excel
TPS (throttle position sensor?) Where would this be if not the MCOR?
|
04-05-2015, 02:55 PM | #7 |
Not Yet Wild
Join Date: Aug 2012
Posts: 38
|
Yea, got that. But how do I get the correct unit if the part number is the same?
|
04-05-2015, 03:06 PM | #8 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Precedent shutdown at full throttle. Excel
What's the part number on the TPS adapter?
|
04-05-2015, 03:10 PM | #9 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Precedent shutdown at full throttle. Excel
Sergio,
There must have been a misunderstanding somewhere. I don't recall ever saying the iq and excel adapters had the same part numbers. They are in fact different, but the IQ one is no longer available. 103682701 is the correct number for Excel cars |
04-05-2015, 03:11 PM | #10 |
Gone Wild
Join Date: Jan 2014
Location: Lafayette, Louisiana
Posts: 1,677
|
Re: Precedent shutdown at full throttle. Excel
David where is this adapter, I don't remember seeing it on mine?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Yamaha G1 Only Runs with full choke and full Throttle | Gas Yamaha | |||
yamaha g2 bogs at half throttle through full throttle | Gas Yamaha | |||
06 CC Precedent moves side to side at full throttle. | Gas Club Car | |||
2010 precedent excel i2 w/excel braking | Electric Club Car | |||
2005 Precedent IQ Going Into Limp Mode At Full Throttle | Electric Club Car |