|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
07-01-2018, 04:00 PM | #11 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: Reverse Buzzer On When Charging
Has to be a wire shorting or grounding out somewhere.... This is so unusual....
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-01-2018, 04:21 PM | #12 |
Not Yet Wild
Join Date: Jun 2018
Posts: 11
|
Re: Reverse Buzzer On When Charging
The voltages going all over the place on the Battery Light on the dash make me think its more than a ground/short.
|
07-02-2018, 07:37 AM | #13 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Reverse Buzzer On When Charging
Please confirm the color of the wires connected to both the "battery warning light" and the "Reverse buzzer" terminals.
|
07-02-2018, 09:06 AM | #14 |
Not Yet Wild
Join Date: Jun 2018
Posts: 11
|
Re: Reverse Buzzer On When Charging
I forgot to mention, that I took out the entire dash and tested the voltages at the 9 Pin wiring harness, also. The voltages there were erratic, also.
I will check the color of the wires in the dash, though, when I get a chance. |
07-04-2018, 12:34 PM | #15 |
Not Yet Wild
Join Date: Jun 2018
Posts: 11
|
Re: Reverse Buzzer On When Charging
Warning Light has Orange and Brown/White going to it.
Reverse Buzzer has Pink and Orange/White going to it. Voltages still erratic at the 9 pin connector upstream of this point with the entire dash disconnected from the rest of the electrical. |
04-10-2019, 04:02 PM | #16 |
Not Yet Wild
Join Date: Jun 2018
Posts: 11
|
Re: Reverse Buzzer On When Charging
So, I had to put this on the back-burner for awhile, but have started thinking about it again. I still have not been able to track this one down.
I noticed today that if I plug in the charging cord to the cart with the charger unplugged from the wall outlet, that the buzzing stops and stays off for awhile even after unplugging the charging cord from the cart. This one sure is puzzling me. Capacitor somewhere? Slow ground? I have tried this with the original charger and a brand new charger. Same results. |
04-11-2019, 08:51 AM | #17 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Reverse Buzzer On When Charging
Sounds a lot like a bad ground connection somewhere. When you plug the charger in you're getting feedback into the dash wiring. This could be literally anything on the cart, but check the ground wires where they all joint at the controller B- terminal first. This is where the OBC battery pack and most other ground wiring on the cart are connected.
When you plug the charger in does it start making the noise right away as soon as the plug is inserted, or does it only start making the noise once the charger actually turns on? Its possible if some mice were doing their business on top of the controller there is damage inside the controller. Those terminals are looking awful corroded in the pic. In the pic above there are red white and black wires that come in from the right side, What do they go to? |
04-11-2019, 12:04 PM | #18 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Reverse Buzzer On When Charging
The erratic voltage on the battery indicator is normal since there is an infrared diode inside that light that sends information to a diagnostic hand-held device.
You can see the infrared diode blink by looking at the battery indicator through your phone's camera. Try disconnecting the 4-pin molex plug from the controller in case there is a short on any those wires that is causing issues with the controller. That connector is not needed for the cart to operate, it is only used to connect the IQDM programmer. Edit: I know You said you checked every wire, but look closely to the "sense" wire which is the gray wire from the charger receptacle that connects to the back of the OBC with a quick connect. Last edited by Sergio; 04-11-2019 at 12:23 PM.. Reason: Comment about the sense wire. |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
wiring a reverse light to the reverse buzzer? | Gas Yamaha | |||
F/r switch help. Reverse buzzer is on in forward and not on reverse | Electric EZGO | |||
Reverse buzzer sounding while charging | Electric EZGO | |||
Reverse buzzer sounds even when not in reverse | Columbia ParCar | |||
reverse buzzer | Electric Club Car |