|
Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
07-11-2016, 08:43 AM | #1 |
Not Yet Wild
Join Date: Apr 2016
Posts: 40
|
08 Drive Won't Move
We had a cart in our fleet quit after three holes over the weekend. We haven't had any problems before with it and the batteries are fairly new and weren't showing any signs of being bad. I haven't actually checked them yet but they are next on the list. I replaced the stop switch, solenoid, and throttle sensor and still nothing. Checked the fuse and that's fine as well. What could be next.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-11-2016, 09:10 AM | #2 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: 08 Drive Won't Move
does the reverse beep & resist rolling when pushed (tow switch on)? does solenoid click when tow/run initally switched on?
|
07-11-2016, 09:34 AM | #3 |
Not Yet Wild
Join Date: Apr 2016
Posts: 40
|
Re: 08 Drive Won't Move
Yes the reverse beeps and resists when pushed and the solenoid clicks.
|
07-11-2016, 10:02 AM | #4 |
Gone Wild
Join Date: May 2012
Location: Rio Verde, Az
Posts: 7,183
|
Re: 08 Drive Won't Move
Does the solenoid click when you push the pedal in both FWD and REV? What are your battery voltages? Sounds like your controller is working if it resists pushing like it should.
|
07-11-2016, 10:24 AM | #5 |
Not Yet Wild
Join Date: Apr 2016
Posts: 40
|
Re: 08 Drive Won't Move
The voltages were all at least 12.6 something. I didn't write them down. I load tested them though and one of them seemed weaker than the rest. It clicked in both fwd and rev. I checked the fwd/rev switch anyways and that worked when replaced too.
|
07-13-2016, 12:09 PM | #6 |
Not Yet Wild
Join Date: Apr 2016
Posts: 40
|
Re: 08 Drive Won't Move
I took the weaker battery and put it on a charger. It seemed fine when I tested it later and the cart still won't move after putting it back in. I'm really at a stand still as I've done everything I can think of that has fixed any of our other carts.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Drive belt hooked up, now cart very hard to move | Gas Columbia ParCar | |||
97 ez-go electric 36v serial drive won't move | Electric EZGO | |||
Yamaha Drive wont move till it warms up | Electric Yamaha | |||
Another drive that wont move! | Electric Yamaha | |||
1996 Series DS 48V won't move on ground, wheels barely move on jacks | Electric Club Car |