lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 05-26-2010, 02:05 AM   #11
rib33024
......................
 
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
Default Re: Testing Batteries on a 36v

Quote:
Originally Posted by papajoe View Post
crap took it for a ten minute spin before I put it away will that be a problem?


6.2 is around 50%, do not run batteries below 50% should be OK
take care of the batteries --and have fun with that cart

Read this and when your done -READ IT AGAIN-----


NEW BATTERY BREAK-IN PROCEDURE:
Following proper break-in procedure can increase the strength and the useful life span of your new batteries. New batteries are initially about 75% of their full strength. The following procedure will insure they reach their full potential.
The 1st 10 to 20 complete charge/discharge cycles are critical to insure they reach 100%. New batteries should be charged before use and thereafter as follows:
Plug the charger in and leave it alone until charger shuts off by itself. Then drive to discharge the batteries to 75% battery pack capacity (see chart) Plug the cart back in and repeat the charge cycle.......It is very important you let it charge until it is completely done. Repeat this for the first 10 - 20 cycles......by the 12th cycle you will notice a difference in power, speed, and run-time.........I have never had a customer say they have not noticed the increase.
Most importantly, NEVER run the battery pack down below 50% of capacity throughout their entire life. Never leave the batteries in a state of discharge for extended periods of time. Recharge the pack once a week if the cart is sitting idle or in storage. And when in doubt, recharge it.
During the break-in procedure, keep an eye on the water levels. T can take 12 hours or more for the 1st few Charging times. These extended charge cycles may evaporate some of the water. ( use distilled water only )
As the batteries break in you will notice the charge time gets shorter. Eventually going from 12 to 5-6 hours per recharge.
ONCE A MONTH:
Routine maintenance is the 2nd most important thing to insure you get the most use out of your new battery pack. It is critical that you get into a routine of spending 10 - 15 minutes a month to keep the cable connections clean and check the water levels. Proper water level is critical. Dry batteries die quickly.
Keep the Distilled Water level up to the bottom of the fill hole sleeve or a half inch above the lead plates. Do not fill to the top.
Use a hard nylon brush to remove any visible corrosion. Carefully check that all of the cable connections are tight. Loose connections cause arching which will melt the soft lead terminals. Spray-on Battery Terminal Protector is available from the auto parts store and greatly reduces corrosive build up.
I hope this helps you get the most use possible out of your battery investment.

Read more about new battery break-in procedures here:

NEW BATTERIES?
http://www.buggiesgonewild.com/electric-club-car/17096-battery-breakin-break-procedure-procedures.html?highlight=Battery+Breakin
rib33024 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 05-26-2010, 09:43 AM   #12
OLD MEC
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: Testing Batteries on a 36v

No if you didnt try and climb a mountain or the like you are OK, but its always best for long battery life and performace to break batterys in correctly. Remember that it will take about 10-15 recharges before batterys will be at full power, and NEVER ALLOW batterys below 50% before recharging or when used recharge each time after use.
OLD MEC is offline   Reply With Quote
Old 05-26-2010, 10:05 AM   #13
scottyb
Happy Carting
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 73,358
Default Re: Testing Batteries on a 36v

Attached Images
File Type: jpg Batterytable1-1.jpg (88.7 KB, 19 views)
File Type: jpg battery2.jpg (18.3 KB, 17 views)
scottyb is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Changed batteries/batteries won't charge Electric Club Car
Recharging Batteries---so charge recognizes batteries!! Electric EZGO
testing batteries Electric Club Car
Testing 1,2,3 Test Post


All times are GMT -5. The time now is 09:23 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.