lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



 
 
Thread Tools Display Modes
Prev Previous Post   Next Post Next
Old 01-21-2014, 06:52 PM   #1
shaferz
Getting Wild
E-Z-GO
 
Join Date: Jul 2010
Location: Illi-noize.
Posts: 98
Default PB-6 Pot specs

Can anyone verify, with 100% certainty, exactly what the spec is on the potentiometer inside of a Curtis PB-6?

I was shipped a cheap knock-off 0-5k. The controller being used is a 0-5V setup. I rewired the cheap knock-off to a 3 wire setup without realizing that the pot is actually like a 270 or 300 degree setup.

I am now being offered a PB-6 - but I need to be sure that I can wire it to work with a 0-5V setup.

This is all on a FSIP 51-42L700NNVS. Terminal 2 on the controller outputs ~5V. Terminal 3 needs to see the full 5v to recognize a full throttle situation.

Can I wire a PB6 like so:

Terminal 1 on the pot (high side)- Wire to terminal 2 on the Controller (this will feed the 5v into the pot.)
Terminal 2 on the pot (wiper)- Wire to terminal 3 on the Controller (this is what the Controller monitors for throttle input.)
Terminal 3 on the pot (low side)- Wire to battery pack ground.

Would doing the above give me 0v (open circuit) to terminal 3 on the controller in a 'no throttle' situation?

Also seems like if the pot was something like a 40-50 degree pot or something, it would allow a full 5v to pass at full throttle...? Since the pot in the cheap knock off is a 270 degree or something - I am only passing ~2v at full throttle at this point. Was hoping that the PB-6 would be the answer.

The seller seems to have absolutely no clue other than saying 'uhh... its a pot box'

HALP! :)
shaferz is offline   Reply With Quote
 
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
G1 torque specs Gas Yamaha
specs g22 357 ccm Gas Yamaha
244 engine specs Gas EZGO
specs Gas EZGO
gas 290 specs Gas Club Car


All times are GMT -5. The time now is 08:54 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.