|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-14-2011, 09:33 PM | #1 |
Gone Wild
Join Date: Jun 2008
Location: New Braunfels,Texas
Posts: 235
|
08 Club Car 48volt wont go...
Carts been fine up till now.Batterys read 44.8...checked each battery an get 11.8-12.2...4x12v batterys
When I put it in reverve...the buzzer goes off...but cart will not go. Where do I start?I don't know squat about electric carts. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-14-2011, 10:02 PM | #2 |
Not Yet Wild
Join Date: Mar 2009
Location: Northern Wisconsin
Posts: 48
|
Re: 08 Club Car 48volt wont go...
Start by reading the State of Charge chart above. Your batteries need charging or are shot.
|
08-15-2011, 06:37 AM | #3 |
Gone Wild
Join Date: Jun 2008
Location: New Braunfels,Texas
Posts: 235
|
Re: 08 Club Car 48volt wont go...
No doubt they need charging....but thats not it.These are Factory 08 Trogan built batterys.Carts been running fine up to now.I misspoke about the44.8...it was 48.4v...uncharged.
|
08-15-2011, 07:13 AM | #4 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 08 Club Car 48volt wont go...
is the soleniod clicking?......................................... ........
|
08-22-2011, 10:25 AM | #5 |
Gone Wild
Join Date: Jun 2008
Location: New Braunfels,Texas
Posts: 235
|
Re: 08 Club Car 48volt wont go...
|
08-22-2011, 11:40 AM | #6 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 08 Club Car 48volt wont go...
if soleniod isn,t clicking and battery voltage is good ( have you tried charging them since cart won,t move ) if not try charger to see if it works then jack the rear of cart up and put a jumper on large posts of soleniod than turn key on put in gear and press pedal see if wheels spin.......if so its either in the activation circuit or the soleniod went bad..............theres a better chance its the soleniod but not always 100%.............................
|
08-23-2011, 07:49 PM | #7 | |
Gone Wild
Join Date: Jun 2008
Location: New Braunfels,Texas
Posts: 235
|
Re: 08 Club Car 48volt wont go...
Quote:
Hmmmm...I guess I have to do more research.I found the motor...but still looking for a solenoid of some kind.Nothing is very accessable on these Club Cars. |
|
08-23-2011, 08:25 PM | #8 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 08 Club Car 48volt wont go...
soleniod should have two 6 gage cables going to it and than some smaller wires i,m not 100% certain where it located on your cart but its in there with the batteries somewhere......on the small side not quite as big as a pop can and either round or square,....................................
|
08-28-2011, 07:14 PM | #9 |
Gone Wild
Join Date: Jun 2008
Location: New Braunfels,Texas
Posts: 235
|
Re: 08 Club Car 48volt wont go...
I'll shoot some pictures tomorrow.We can go from there....but after more reading...an questioning the lot manager...Me thinks he blew a controller.Cart was left in "run" mode when he messed with batterys.He told me he had a loud BOOM an acid went flying.Everything looks okay....but I'll dig further.
|
08-30-2011, 06:29 AM | #10 |
Mr. Helper
Join Date: May 2009
Location: NY Catskills & South carolina
Posts: 445
|
Re: 08 Club Car 48volt wont go...
i smell burnt controller..........
which controller do you have and what is the model # of it |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Converting 48volt yamaha charger to 1998 48volt club car | Electric Club Car | |||
99 48volt club car | Electric Club Car | |||
700amp 48volt ITS logisystems/48volt delta q charger | Golf Carts and Parts | |||
97 48volt clubcar series wired wont go | Electric Club Car | |||
97 club car 48volt | Electric Club Car |