lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 08-30-2013, 05:28 PM   #1
MuckSavage
Gone Wild
 
MuckSavage's Avatar
E-Z-GO
 
Join Date: Jan 2013
Location: Turnersville, South Jersey
Posts: 220
Default Run - Tow/maint. Switch question

I was backing my part up the driveway into the garage & it suddenly stopped (no F/R, no buzzer, etc) I'm going thru the FSM troubleshooting flow chart. I got to step 62, and it tells me to replace the run/tow switch. I ran a continuity check across the switch and it seems okay. My voltages at the back of the switch are;
Red/white 31.4(t), 2.2(r). Red 38.2(t), 38.2(r). Red/yellow 30.9(t), 38.2(r). Orange/red 00.6(t), 2.1(r)

(t)=tow/maint, (r)=run.

I have no reverse buzzer & not even a solenoid click so I can't run the diagnostics. Any help is appreciated.
MuckSavage is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 08-30-2013, 05:43 PM   #2
JohnnieB
Techno-Nerd
 
JohnnieB's Avatar
E-Z-GO
 
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
Default Re: Run - Tow/maint. Switch question

Sounds like a Reed Switch failure.
Check for Battery pack voltage on the smaller of the three wires coming out of the charge receptacle.

If you get it there, check for pack voltage on J1 Pins 4 & 5. Those two should be live 100% of the time when charger isn't plugged into cart.
Attached Images
File Type: jpg Charger receptacle - Reed Switch.JPG (73.5 KB, 0 views)
JohnnieB is offline   Reply With Quote
Old 08-31-2013, 07:34 AM   #3
MuckSavage
Gone Wild
 
MuckSavage's Avatar
E-Z-GO
 
Join Date: Jan 2013
Location: Turnersville, South Jersey
Posts: 220
Default Re: Run - Tow/maint. Switch question

I have 28v on the reed switch wire. 38.2v on pin 4, 30.2v on pin 5. This while inserting the probe into the backside of the J1 plug. Where to next?
MuckSavage is offline   Reply With Quote
Old 08-31-2013, 08:30 AM   #4
JohnnieB
Techno-Nerd
 
JohnnieB's Avatar
E-Z-GO
 
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
Default Re: Run - Tow/maint. Switch question

You're getting some strange voltage readings. Voltage coming from Reed switch is lower than voltage on J1 Pin-4, which is the other end of same wire.
Corroded connections? Bad test leads? Low battery in DVM?

Anyway the PDS is a fly-by-wire system and the controller does everything. The external switches and stuff only tell the controller what to do.
To get the controller to energize the solenoid, six sets of contacts in five switches have to be closed.
1. Reed switch
2. Run/Row switch (2 sets of contacts)
3. Keyswitch
4. F/R switch (Either F or R contacts)
5. Pedal switch

Attached is a schematic with the solenoid activation circuit highlighted.
You should have FULL battery pack voltage on all wires highlighted in red.
Attached Images
File Type: jpg Wiring Diagram - PDS - Solenoid activation traced.jpg (69.7 KB, 0 views)
JohnnieB is offline   Reply With Quote
Old 08-31-2013, 06:11 PM   #5
MuckSavage
Gone Wild
 
MuckSavage's Avatar
E-Z-GO
 
Join Date: Jan 2013
Location: Turnersville, South Jersey
Posts: 220
Default Re: Run - Tow/maint. Switch question

Got it! 1. I switched up to a different DVOM & measured correct voltage.
2. I followed the schematic & found a loose j4 plug. Thank you JohnnyB!
MuckSavage is offline   Reply With Quote
Old 09-01-2013, 06:56 AM   #6
JohnnieB
Techno-Nerd
 
JohnnieB's Avatar
E-Z-GO
 
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
Default Re: Run - Tow/maint. Switch question

Glad to hear you got it going.
JohnnieB is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
Run / Tow Maint. Switch AMP rating Electric EZGO
Any way to put a "maint mode switch" in? Gas Club Car
2002 PDS Tow/Maint. Switch during charging Electric EZGO
Battery Maint. Question Electric Club Car


All times are GMT -5. The time now is 04:39 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.