|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-06-2021, 06:53 AM | #1 |
Not Yet Wild
Join Date: Aug 2021
Posts: 5
|
2002 TXT Series Issue- Experts please read
Calling all experts. PLEASE READ.
Issue: 2002 Txt series cart. Works intermittently. Will run and die out of nowhere. Click and no go. Everything else works electronically. Hardware: -Dec 2020 Trojan Batteries all Test perfect. -New FNR switch -ITS tested fine -Alltrax NPX (non programable)- 4 blink green and solid green all good there. -Solenoid tests good… I had it with a repair guy and was told it never acted up while he had it. All connections are tight. Has a new FNR switch and no hot cables. Will literally run 5 miles and just stop.. or spend the night in the garage and not want to move. So cold or hot it does not make a difference. When it happens, I tend to rock the FNR handle back and forth and attempt to move. It will come alive in one direction sometimes. One direction first and then work in both directions. Sometimes I shake the cart as it happens when in transport on the trailer as well. I know many will say tighten connections, but they are tight trust that. After miles of riding the motor is warn but not hot to the touch. I already bypassed the reed switch. I just want this cart to run reliability until the batteries are depleted as designed. The last owner was so fed up with it he sold it to me for cheap after buying new batteries and a FNR switch. I cant let my wife and family take it and be stranded. Any ideas? I have limited knowledge but am learning. Thank you in advance. Pics are of the actual cart. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-06-2021, 07:03 AM | #2 |
Gone Wild
Join Date: Sep 2010
Location: Florida
Posts: 1,895
|
Re: 2002 TXT Series Issue- Experts please read
when it stops running try tapping on the motor end cap with a hammer and try it again directly afterwards...it may be your motor brushes are sticking due to carbon build-up...this is the case a lot more in lifted carts that carry weight often...something easy to try that's a dead givaway...
|
08-06-2021, 09:09 AM | #3 |
Not Yet Wild
Join Date: Aug 2021
Posts: 5
|
Re: 2002 TXT Series Issue- Experts please read
I'll give that a try. Thank you.
|
08-06-2021, 12:51 PM | #4 |
Not Yet Wild
Join Date: Apr 2021
Location: CB, NC
Posts: 48
|
Re: 2002 TXT Series Issue- Experts please read
I did notice that the cable coming off of the lest negative terminal of your battery pack appears to be less of a gauge than the others? It might just be the picture? If it is smaller then you might want to check all the other cables not in the picture. Not saying that this is your problem but it would affect your performance (weakest link in the chain) and might cause some heat issues.
|
08-06-2021, 01:34 PM | #5 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 2002 TXT Series Issue- Experts please read
1. Get rid of the controller cover. The NPX is designed to have air circulating around it, so it may be going into thermal shutdown. (And under the cover, you cannot see the LED, so you can't see the blinked error code. 4 red flashes for overtemp)
2. More than one problem very likely since it also won't run from a cold start. Get some clip leads for your DVM and connect the test leads to the controller's B- and M- terminals. Monitor voltage while driving cart. Should be full pack voltage (38.2V fully charged) when pedal is pushed just far enough to make solenoid click and should decrease down to about 0V with pedal on floor. |
08-06-2021, 01:46 PM | #6 |
Not Yet Wild
Join Date: Aug 2021
Posts: 5
|
Re: 2002 TXT Series Issue- Experts please read
10-4 I'll give it a look as well. Thanks
|
Tags |
click, ezgo, nogo, series, txt |
|
|
Similar Threads | ||||
Thread | Forum | |||
2002 EZGO TXT Series | Electric EZGO | |||
2002 ezgo series car | Electric EZGO | |||
2002 DS 48v Series NEED HELP! | Electric Club Car | |||
2002 EZ GO 36V Series, Wont go | Electric EZGO | |||
2002 Series 48v Club Car | Golf Carts and Parts |