|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
12-09-2012, 05:39 PM | #1 |
Not Yet Wild
Join Date: Dec 2012
Posts: 2
|
ezgo no power
While installing a new body on my 2000 ezgo the 2 cables from the charging port touched and burnt some wires, now I have no power at all, I have a battery meter installed and it's not even coming on. My lights work but that's all. Where should I start on fixing my problem thanks.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-09-2012, 06:20 PM | #2 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: ezgo no power
Welcome to BGW!
Now you know why electric carts are called "Sparkies". The lights probably run off a 12V tap on the battery pack and the bad battery or cable is further down the series loop. Check the fuses, there may be one in the high current circuit to the controller and there might be one in the white wire from the charge receptacle. Connect the negative test lead of your DVM to the battery pack's main negative terminal and start moving the postive test lead to the positive posts on the batteries in the series chain. (see attached drawing) When the voltage stops getting higher in about 6V steps, the problem is betwen the last place it did and the first place it didn't. |
12-09-2012, 06:41 PM | #3 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,410
|
Re: ezgo no power
It is likely you burnt the reed switch out in the charge port. This provides + power to the ignition circuit. If that is what happened there is no need to replace it, just pull 36v+ from the main battery terminal and you will be okay.
Below is a pic of the reed switch in my cart. |
12-09-2012, 08:28 PM | #4 |
Not Yet Wild
Join Date: Dec 2012
Posts: 2
|
Re: ezgo no power
Thanks for the replys I will test them at tomorrow, is it possible that when it sparked it messed up the controller or solenoid
|
|
|
Similar Threads | ||||
Thread | Forum | |||
01 ezgo pds no power | Electric EZGO | |||
Ezgo dies under power then regains power | Electric EZGO | |||
86 ezgo-no power | Gas EZGO | |||
96 ezgo dcs wants more power!!! | Electric EZGO | |||
have power on ezgo buggy no power light | Electric EZGO |