|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
05-15-2018, 10:03 AM | #1 |
Not Yet Wild
Join Date: May 2018
Posts: 9
|
This sound like a charging issue or something else?
Disclaimer: I have never worked on my golf cart so if I sound like an idiot, it’s because I am a total noob at this.
My cart is a 2009 Precedent I2 Excel Club Car. So it had been sitting up for about a year. This last week I bought new batteries and installed them over the weekend. Thing is while the lights came on and the reverse buzz came on the cart did nothing but click when I pushed down on the accelerator. I also noticed that the rubber end of the charging cable that plugs into the cart was really warm…a good bit warmer than I would have expected. Anyway, I decided to try charging it overnight last night. The charger was still on this morning so out of curiosity I unplugged it and pushed on the accelerator. To my surprise it moved but it just kept starting and stopping….jerking like it was getting power and then not getting power if that makes sense. Possible the batteries maybe aren’t charged enough even though they charged al night….I don’t know. Any thoughts? Thanks for any advice. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-15-2018, 10:08 AM | #2 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: This sound like a charging issue or something else?
Make sure the red wire from the charger receptacle is connected to the pack positive battery post.
|
05-15-2018, 10:19 AM | #3 |
Not Yet Wild
Join Date: May 2018
Posts: 9
|
Re: This sound like a charging issue or something else?
|
05-15-2018, 10:21 AM | #4 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: This sound like a charging issue or something else?
Look at the back battery under the passenger side.
There should be a 10ga red wire on the same post as the big 6ga RED cable that goes to the Solenoid. |
05-15-2018, 10:57 AM | #5 |
Not Yet Wild
Join Date: May 2018
Posts: 9
|
Re: This sound like a charging issue or something else?
|
05-15-2018, 11:08 AM | #6 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: This sound like a charging issue or something else?
Not sure what type of batteries you have or how long they were on your distributors shelf, but many times after installing new batteries my chargers have ran the full 16 hours and timed out. After that, I would reinstitute another charge (disconnect the charge cable, wait a few seconds and plug it back in) and after several more hours, it would reach a fully charged state and my charger would cut off.
Though yours would have had to be dead (and the charger would not have came on) for what you describe, but never the less, I would inspect all my cables for integrity and tightness and then go back to charging while periodically monitoring the pack voltage with a DVM. 61vdc - 63vdc would be common. It will shut off when fully charged. P.S. And please make sure all your batteries are installed and series'd together correctly. |
05-15-2018, 11:52 AM | #7 | |
Not Yet Wild
Join Date: May 2018
Posts: 9
|
Re: This sound like a charging issue or something else?
Quote:
|
|
05-15-2018, 11:55 AM | #8 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: This sound like a charging issue or something else?
That is where is should be. As the voltage rises the amperage will lower as it is topping of the pack charge.
This is why you have to wait 12-24 hours afterwards to get a "true" pack voltage. |
05-15-2018, 12:01 PM | #9 |
Not Yet Wild
Join Date: May 2018
Posts: 9
|
Re: This sound like a charging issue or something else?
So if that's the case then it's probably not that the charger isn't providing enough juice but something with the cart. Originally I ordered a solenoid replacement but canceled it when the cart moved this morning thinking it might be something else.
|
05-15-2018, 02:28 PM | #10 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: This sound like a charging issue or something else?
You are best to troubleshoot in sequence. First starting with a fully charged pack and then go out from there if needed...
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Charging Issue 99 DS | Electric Club Car | |||
2006 EZGO TXT issue no sound in R / won't move | Electric EZGO | |||
Over Charging Issue | Gas Club Car | |||
Charging issue, but deeper issue? | Gas Columbia ParCar | |||
Charging Issue/ Battery Issue? | Electric EZGO |