|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
07-29-2010, 08:35 PM | #1 |
Not Yet Wild
Join Date: Jul 2010
Location: Port Aransas, TX
Posts: 35
|
G22 Cuts and dies when it gets warm
2006 G22, runs good when cold, after about 1/2 mile it begins to cut out then dies. I can put it into neutral rev it then get it going again. I then go a few hundred feet then the same cutting out and dies, sometimes I get a backfire too. Eventually it won't run until cool.
I checked all gas lines, replaced the vacuum line, cleaned the carb, put in new plug and filter. Any suggestions? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-29-2010, 10:28 PM | #2 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: G22 Cuts and dies when it gets warm
Smallblock, says to check the small 16 gage wire, on the ground lug, with a pin connecter, going into the main wire harness, just in front of the generator. This 16 gage wire is connected with the large battery cable, on the ground lug, on the passenger side of the generator. the pin connector comes loose from the main harness and raises all kinds of heck.
Read this slow, and hope this makes sense. |
07-30-2010, 11:24 AM | #3 |
Not Yet Wild
Join Date: Jul 2010
Location: Port Aransas, TX
Posts: 35
|
Re: G22 Cuts and dies when it gets warm
I checked that wire and it looks good.
Thanks |
07-30-2010, 04:47 PM | #4 |
Not Yet Wild
Join Date: Jul 2010
Location: Port Aransas, TX
Posts: 35
|
Re: G22 Cuts and dies when it gets warm
Solved the problem, it was starving for gas.
The vacuum hose was smashed under the airbox, re-routed it and runs perfect. |
07-30-2010, 06:32 PM | #5 | |
Sometime's............
Join Date: Oct 2007
Location: Tacoma Washington
Posts: 11,874
|
Re: G22 Cuts and dies when it gets warm
Quote:
|
|
07-30-2010, 06:33 PM | #6 |
Sometime's............
Join Date: Oct 2007
Location: Tacoma Washington
Posts: 11,874
|
Re: G22 Cuts and dies when it gets warm
|
07-30-2010, 07:01 PM | #7 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: G22 Cuts and dies when it gets warm
Cool,
Glad you got it going. I'd hate it if mine didn't run. Small block, You've helped so many people fix their cars, and we all thank you! Mike |
|
|
Similar Threads | ||||
Thread | Forum | |||
2001 club car cuts out and backfires after warm | Gas Club Car | |||
Warm Batteries | Electric EZGO | |||
88 EZ go, no start after getting warm | Gas EZGO | |||
Engine cuts off | Gas Club Car |