|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-10-2021, 10:07 AM | #1 |
Not Yet Wild
Join Date: Aug 2020
Posts: 18
|
97 ezgo gas with robin 295/no spark
working on a 97 gas ezgo with robin 295. new pick up, new coil, and new ignitor. sparks once when first starts cranking and sometimes once when the pedal is released. i'm stumped, any ideas
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-10-2021, 10:27 AM | #2 |
Vintage tech
Join Date: Sep 2009
Location: South
Posts: 3,216
|
Re: 97 ezgo gas with robin 295/no spark
Battery is not in backward is it ?
Did it start this all of sudden ? Are these parts OEM or aftermarket ? |
09-10-2021, 11:02 AM | #3 |
Not Yet Wild
Join Date: Aug 2020
Posts: 18
|
Re: 97 ezgo gas with robin 295/no spark
battery is correct
all oem parts customer said problem accured after cart was washed |
09-10-2021, 12:14 PM | #4 | |
Vintage tech
Join Date: Sep 2009
Location: South
Posts: 3,216
|
Re: 97 ezgo gas with robin 295/no spark
Quote:
What are marking on this OEM ignitor ? take a picture of it and post what it looks like. |
|
09-10-2021, 12:55 PM | #5 |
Gone Wild
Join Date: Jul 2020
Location: NC
Posts: 773
|
Re: 97 ezgo gas with robin 295/no spark
I am guessing a bad ground wire connection somewhere in the vicinity of the battery or solenoid or it's a wire came loose at the solenoid or at one of the connections between the solenoid and igniter or igniter and pulser coil.
|
09-10-2021, 01:53 PM | #6 |
Not Yet Wild
Join Date: Aug 2020
Posts: 18
|
Re: 97 ezgo gas with robin 295/no spark
if i unplug the pulser coil while cranking and plug it back it will spark 1 time everytime i plug it back together only 1 spark
i also had another exact same cart so i switched ( 1 AT A TIME ) the coil the igniter the pulser coil and all the parts worked on the other cart but the problem cart still did the same thing ... also checked all connections even tried using seperate 12v batt source for igniter. im at a loss |
09-10-2021, 02:52 PM | #7 |
Gone Wild
Join Date: Jul 2020
Location: NC
Posts: 773
|
Re: 97 ezgo gas with robin 295/no spark
Have you put new plugs in? sounds like grounding issue to me. Add a jumper wire from the battery negative terminal to the ground side of the solenoid(small terminal) and try it.
|
09-10-2021, 04:22 PM | #8 | |
Vintage tech
Join Date: Sep 2009
Location: South
Posts: 3,216
|
Re: 97 ezgo gas with robin 295/no spark
Quote:
|
|
09-14-2021, 07:47 AM | #9 |
Not Yet Wild
Join Date: Aug 2020
Posts: 18
|
Re: 97 ezgo gas with robin 295/no spark
tried the ground to the solenoid , still one spark checked connection on the pulser coil , all good
|
09-14-2021, 08:40 AM | #10 |
Gone Wild
Join Date: Jul 2020
Location: NC
Posts: 773
|
Re: 97 ezgo gas with robin 295/no spark
Make sure the ground at the motor isn't up against the plastic housing and is actually up against the block. If all the components check out on another machine, then it is down to either wiring, or configuration on the subject machine. Clean the contacts on the pulsar coil, I have had gunked up pulsar coil pick ups cause failure to spark. Not sure about the one spark issue though. Look closely at the flywheel as well.
If all is well there, pull the coverings off the wire looms between the solenoid area and the front of the engine, inspect each wire, and every connector. Can't just Ohm them as a few strands connected might pass the continuity test, but not handle the load to create spark. Post some close up photos of the wiring at the solenoid, at the reverse switch, and at the front of the motor to include the pulsar coil, ignition coil, and grounds. |
|
|
Similar Threads | ||||
Thread | Forum | |||
No spark on a 2005 350 ezgo robin | Gas EZGO | |||
98 ezgo Robin pre mci No spark after changing S/G | Gas EZGO | |||
spark help robin 244 | Gas EZGO | |||
98 EZGO gas 295 robin engine no spark | Gas EZGO | |||
83 Robin EZGO has spark no start | Gas EZGO |