|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
06-03-2017, 07:45 PM | #1 |
Not Yet Wild
Join Date: May 2017
Location: California
Posts: 7
|
G1 Problems
Hey ya'll i got a G1 85 so it would stall going down hills took carb apart float stuck adjusted it so it would close. Now once i run it for a bit it wont idle throttle up i pulled fuel line its squirting gas good and fuel filter is full? Im mixing gas not using injector. Checked exhaust butter fly its working and the throttle link is moving im super lost any direction would be great someone told me of flaps behind carb causing flooding any possibility on this? Also some times if i pump gas quickly it seems to go?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-04-2017, 07:33 AM | #2 |
Gone Wild
Join Date: Jan 2017
Location: venice
Posts: 1,807
|
Re: G1 Problems
you shouldn't have had to adjust the float just clean the seat and the other passages. if you adjusted the float the bowl maybe running out of fuel
|
06-04-2017, 09:04 AM | #3 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: G1 Problems
As for the "flaps behind the carb" thats you Reed valve if you are getting fuel blow back into the air filter then the reeds are bad but vary rarely they go bad
|
06-04-2017, 10:11 AM | #4 |
Searching for The Way
Join Date: Oct 2009
Location: Medina, Ohio (NEOHIO)
Posts: 11,436
|
Re: G1 Problems
Did you check compression?
These G1's are known for the crank seals to go bad. Look behind the clutch, is there wet oil near the crankshaft? If so, seals are bad. This will cause poor running and low power. |
06-04-2017, 11:43 AM | #5 |
Not Yet Wild
Join Date: May 2017
Location: California
Posts: 7
|
Re: G1 Problems
I adjusted the float because when i manually pushed it up and blew into the fuel line it didnt close.
On the compression note when it warms up this could cause a loss of power at that point. It almost seems like it has a cold start injector that doesnt ahut off like a Toyota even though i know it doesn't. |
06-04-2017, 11:46 AM | #6 |
Gone Wild
Join Date: Jan 2017
Location: venice
Posts: 1,807
|
Re: G1 Problems
theres a service manual for download in the garage section that will help.
|
06-04-2017, 12:56 PM | #7 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,443
|
Re: G1 Problems
If it loses power when hot, bad idle hot, and all is good when cold that is classic 2 stroke for worn out or bad seals. Its losing compression. If the rings/cylinder are worn it will do that, sometimes bad seals get worse with heat too but usually seals make them hard to start you have to choke it a lot to start.
|
06-04-2017, 07:25 PM | #8 |
Not Yet Wild
Join Date: May 2017
Location: California
Posts: 7
|
Re: G1 Problems
Ya i dont have to choke it it fires up and runs like a beast till it gets hot i do a compression test at cold then hot and see if it is reading any different ill post what i find thanks for all your help.
|
06-05-2017, 03:28 PM | #9 |
Gone Wild
Join Date: Jan 2017
Location: venice
Posts: 1,807
|
Re: G1 Problems
is your fuel tank vent working maybe its starving for fuel?
|
06-05-2017, 05:57 PM | #10 |
Not Yet Wild
Join Date: May 2017
Location: California
Posts: 7
|
Re: G1 Problems
No its getting fuel i even pulled the float bowl off when it started acting up and it had plunty of gas in it? The previous owner put some cheap ebay carb on it could this be an issue?
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
ok problems problems problems | Electric Club Car | |||
Big problems>>>> | Electric EZGO | |||
problems with yet another 89 | Gas EZGO | |||
possble battery problems or possible charger problems? | Extreme DC! | |||
6 passanger trouble shooting. Controller problems/gas/or brake problems. | Electric EZGO |