|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-21-2012, 05:31 PM | #1 |
Not Yet Wild
Join Date: Aug 2011
Posts: 29
|
HEI Mod, Cold Air Intake, New Muffler and now have Issue
I did the HEI Mod, Cold Air Intake and New Muffler and now have a issue. The cart didn't have this issue before I did the Mods. What is happening is the cart runs great I can race up and down the rode and it just fly's right along. It appers to act up on the large hills when I go up them, It boggs right down and can only give it a little gas and it crawls up them at a slower than walking pace.. It also has a ticking sound under the seat when it acts up. It acts like it runs fine and then gets hot and boggs out. I let it sit a bit and can go flying around again. The hills might just be a coincadince as it has done it after driving around without going up hills.
I sanded the paint of were I mounted the module and used dialtic grease and grounded it to the frame with a batt cable as well. I ground the tabs off the module as well. It sure seems like something is getting hot or a bad ground but I just don't think so. I'm stumped any idea's of what to try.. Should let all know its and 84 Ezgo.. Last edited by pifd; 08-21-2012 at 05:32 PM.. Reason: More Info |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-21-2012, 05:46 PM | #2 |
nimda
Join Date: Jun 2007
Posts: 13,022
|
Re: HEI Mod, Cold Air Intake, New Muffler and now have Issue
sounds like its running lean. Anytime you add to its ability to move air in and out you'll get a lean condition unless you jet accordingly. I bet if you put the old filter box back on it will run better. (unless its clogged all to crap)
|
08-21-2012, 09:12 PM | #3 |
Gone Wild
Join Date: Feb 2011
Posts: 1,515
|
Re: HEI Mod, Cold Air Intake, New Muffler and now have Issue
Right on Roady air box yes. 2 cycle doesn't like open air unless jetted for the air and don't like exhaust tampered with unless rejetting the carb. My thought everyone wants to create a monster. Speed cost $$$$ how fast you want to go
LOU |
08-21-2012, 09:15 PM | #4 |
nimda
Join Date: Jun 2007
Posts: 13,022
|
Re: HEI Mod, Cold Air Intake, New Muffler and now have Issue
When you jet it right it'll probly run a WHOLE lot better.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
cold air intake | Gas Club Car | |||
Cold Air Intake Install 2pg | Gas EZGO | |||
cold air intake | Gas EZGO | |||
cold air intake | Big Block Talk! | |||
89 ez go muffler and gen belt issue | Gas EZGO |