|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
03-25-2013, 06:47 PM | #1 |
Not Yet Wild
Join Date: Mar 2010
Location: San Diego, CA
Posts: 69
|
G1 choke removal help
Alright, I got the kids a G1 for cheap.. and it runs. But I'm taking everything off and getting it looking good. Not sure why, they will just beat the hell out of it. But I'm removing the front body clip and trying to remove that small fiberglass piece the key and choke cable go into.
How the hell do you get that choke cable out of that hole? Does the rubber part you grab onto when you engage choke come off? That big rubber piece isn't going through that hole. Thanks guys. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-25-2013, 06:52 PM | #2 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: G1 choke removal help
My old G1 choke knob had a small set screw that needed to be loosened. Then the knob could be unscrewed from the cable shaft. Then the nut could be taken off and the cable slipped through the back side of the dash.
|
03-25-2013, 07:36 PM | #3 |
Gone Wild
Join Date: Aug 2012
Location: NE Ohio
Posts: 197
|
Re: G1 choke removal help
What he said...that is how my new one is.
|
03-25-2013, 11:33 PM | #4 |
Not Yet Wild
Join Date: Mar 2010
Location: San Diego, CA
Posts: 69
|
Re: G1 choke removal help
You mean that obvious set screw on the side that I didn't notice? Thanks guys. Guess I need to drink after I'm done working on it, not during
|
03-26-2013, 06:45 AM | #5 |
Searching for The Way
Join Date: Oct 2009
Location: Medina, Ohio (NEOHIO)
Posts: 11,436
|
Re: G1 choke removal help
LOL! Don't feel bad, I was looking all over for the 14mm wrench to remove my shocks. Looked under, behind, above, cleaned out my wrenches drawer, must've been 30 minutes looking for it.......it was in my back pocket! LOL
|
03-27-2013, 11:16 AM | #6 |
Gone Wild
Join Date: Aug 2012
Location: NE Ohio
Posts: 197
|
Re: G1 choke removal help
Don't feel bad...I was up in arms on how to install the new cable until a buddy said "take this off with this screw" while holding the pull handle... :)
Old cable broke, so it wasn't an issue removing it! |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Choke me | Gas Club Car | |||
RXV GAS Choke Cable Removal | Gas EZGO | |||
g1 and the choke | Gas Yamaha | |||
g1 choke | Gas Yamaha | |||
My G1 needs too much Choke | Gas Yamaha |