|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
08-07-2013, 07:03 PM | #1 |
Gone Wild
Join Date: May 2011
Location: North East Tn.
Posts: 1,029
|
Click only when gas pedal is pushed
I have a 2001 G-20 (just like a G-16 only Limo) gas 301cc and when I push the gas pedal all it does is click 1 time for each time I push it. I drove it all day last Wed. with no problem and it has not done anything like this since I got it 3 years ago. I have been gone a few days and got on it today and this happened. I checked the battery voltage it was 12.75 so I charged it for a few hours and checked it again it was 13.54 thats as far as I've got. I did search and the only thing I found is posted below. It will be Sat. before I can get some help to check anything ( still recuperating from my shoulder surgery ) just thought I'd see if these thing's were all I needed to look at.
Thank's for any help, LURCH!!!!!! Possible reasons: 1. Loose negative connection. Check negative pole of battery; tighten if loose. 2. Loose connections in solenoid and/or solenoid not properly grounded. 3. Faulty solenoid. Check by shorting the two large solenoid poles. 4. Faulty battery (low voltage; drained) 5. Problem with starter/gen like loose connection, worn carbon brush, etc. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-07-2013, 09:58 PM | #2 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: Click only when gas pedal is pushed
I'd check "sticky" "so your yami won't turn over". Then start looking at brushes in starter.
|
08-07-2013, 10:13 PM | #3 |
I Refuse To Get Stuck!!!
Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
Re: Click only when gas pedal is pushed
Start with testing for voltage going thru the solenoid when the pedal is pushed.If you have,for ex. 12.7 volts at battery stud on sol.,then you press the pedal and have the same on the other large post,check the voltage at the other end of the wire at the starter,also check the grounds.If you press the pedal,and no voltage or very little shows on output stud,the solenoid is bad.If you have good voltage at the studs,and at the starter,pull it and check it out,or have it tested.Also try turning the pulley a bit,then press the pedal,the armature could have a bad-spot.My Wifes' does that,I need to get a new armature this winter.Hope this helps.
|
08-08-2013, 05:29 PM | #4 |
Gone Wild
Join Date: Jul 2008
Location: Reddick IL
Posts: 11,220
|
Re: Click only when gas pedal is pushed
Also check voltage of the battery when trying to start, the battery may be only taking a surface charge.
|
08-08-2013, 10:00 PM | #5 |
Gone Wild
Join Date: May 2011
Location: North East Tn.
Posts: 1,029
|
Re: Click only when gas pedal is pushed
Thanks guys I'll check it out as soon as I get some help!!!!
|
08-08-2013, 10:13 PM | #6 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,445
|
Re: Click only when gas pedal is pushed
Every time mine did that it was the battery posts. I finally filed the posts and inside the clamps, even the wire brush cleaners would not take care of it. And they didn't look dirty really, just gray.
|
08-09-2013, 12:31 AM | #7 |
Gone Wild
Join Date: Oct 2012
Posts: 1,733
|
Re: Click only when gas pedal is pushed
My g29 the start/stop switch went out behind the accelerator. Was getting 12.5 volts comming In but only 2.5 volts comming out. Inside the ball bearing and spring came loose And was causing a short. So bad that the metal casing on the switch itself was so hot you couldn't touch it. Ordered a new switch and all is well.
|
08-15-2013, 08:10 AM | #8 |
Gone Wild
Join Date: May 2011
Location: North East Tn.
Posts: 1,029
|
Re: Click only when gas pedal is pushed
I got the cart checked out last night and found the problem. The rebuilt starter/gen. I put on when I done the build has a bad spot in it. I got it on the lift looked at a few things, my buddy grabbed the pulley and turned it and (Bam) it started. I will need to take it apart and check the internals and go from there.
Guys, thanks for all your help as always you all are the greatest. LURCH!!!!! |
08-15-2013, 08:21 AM | #9 |
Gone Wild
Join Date: Oct 2012
Posts: 1,733
|
Re: Click only when gas pedal is pushed
Nothing makes you feel better than figuring it out without paying a repair shop to do it for you.
|
08-15-2013, 04:36 PM | #10 |
Gone Wild
Join Date: May 2011
Location: North East Tn.
Posts: 1,029
|
Re: Click only when gas pedal is pushed
You, got that right. I hadn't even set on a cart until about 3 years ago, I bought 2 pieces of junk and fixed 1 to sell then this one to keep. All with the help and support from the members on here. Everyone have a great day.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
club car won't go some times when pedal pushed, hear click | Electric Club Car | |||
Not starting when pedal pushed! | Gas Yamaha | |||
Pushed pedal and nothing happened | Electric EZGO | |||
Jumpy when pedal pushed | Electric Yamaha | |||
Hesitation After Pedal Pushed | Electric Club Car |