club car iq problem

[shadowman]

if batteries are all good and sensor is good it has to be in the speed system somewhere or the controller i would think....................................

[Backwoods Bogger]

still having problem with cart, it has lost speed and has very little power to get up hills

[shadowman]

you have a F&R lever not the rocker switch right?......did you by chance check the motor brushes?............................

[Backwoods Bogger]

i have the rocker switch with the data port under the bottom, also i have not checked the brushes

[shadowman]

have you paid any attention to the resistor coil mounted either behind the batteries or on the 2nd soleniod? drive the cart a 100 ft or so and see if that coil is starting to glow red...........................

[Backwoods Bogger]

i have looked but i only see one solenoid on mine, maybe i am just over looking it

[gaminde]

I do not think an iq cart has this solenoid I think it's done with controller

[shadowman]

Originally Posted by gaminde

I do not think an iq cart has this solenoid I think it's done with controller

i,m not 100% certain either but if it has one it should be rear drivers side if you have the access panel take it off and look it would be right there if it has a 2nd one......if it is done with the controller than problem may be with the controller...............i,m looking at 2 different diagrams one shows without 2nd soleniod one with 2nd soleniod..............both have run tow switch and rocker switches.......................................... .....

[Backwoods Bogger]

i do not have the second solenoid, i put the volt meter on the pack and rode around, it seems to be holding steady at 48.6 volts, also my accelerator pedal moves alot before the solenoid clicks, the solenoid clicks about 1 inch from the floor, thinking this may be my problem is there anyway to adjust the pedal so the solenoid engages sooner?

[shadowman]

the linkage should be adjustable....................................