|
Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
05-01-2016, 08:11 PM | #1 |
Not Yet Wild
Join Date: Apr 2016
Location: Drunken Slumber, Wisconsin
Posts: 33
|
G29 charging, discharging, monitoring questions
2012 ydre. I installed a Curtis 48v battery gauge the other day. Showed full, went 2 miles, batteries died. Got home and put on charger. Charger ran for about 10 hours steady. Pack was DEAD apparently. After full charge, pack read 49.2 volts. Gauges said full. Drove a few miles, gauge went down 1 click. 48.8 volts. Drove a couple more miles, gauge went down 2 more clicks. 48.2 volts. Drove couple more miles. 2 more clicks down on gauge, 46.9 volts. Drove it 2 more miles home. Gauge was on 2nd to last spot. 46.2 volts. Hooked to my charger, it says power on, flashes all the lights briefly, illuminates green for 'charged'. Clicks off. Pack still at about 46 volts. Gauge says full. Batteries are new per dealer I bought cart from. 6 8v USA battery vgc8. HELP.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-01-2016, 08:20 PM | #2 |
Not Yet Wild
Join Date: Apr 2016
Location: Drunken Slumber, Wisconsin
Posts: 33
|
Re: G29 charging, discharging, monitoring questions
Checked each individual battery. Lowest is 7.88v highest is 7.93v
|
05-01-2016, 09:10 PM | #3 |
Gone Wild
Join Date: May 2012
Location: Rio Verde, Az
Posts: 7,170
|
Re: G29 charging, discharging, monitoring questions
Those final voltages are very low! Look at the State of Charge Charts for 48V. Do not run them that low often or they will not last long. I would check on the state of those batteries because they don't sound too good.
|
05-01-2016, 10:14 PM | #4 |
Not Yet Wild
Join Date: Apr 2016
Location: Drunken Slumber, Wisconsin
Posts: 33
|
Re: G29 charging, discharging, monitoring questions
what do I do about charger? Still comes on, cycles all lights, and illuminates green for 'charged'
|
05-01-2016, 11:22 PM | #5 |
Gone Wild
Join Date: Dec 2013
Location: SE Louisiana
Posts: 257
|
Look into a new charger
Sent from my SAMSUNG-SM-N910A using Tapatalk |
05-02-2016, 01:11 AM | #6 |
Not Yet Wild
Join Date: Apr 2016
Location: Drunken Slumber, Wisconsin
Posts: 33
|
Re: G29 charging, discharging, monitoring questions
Recommendations on a new charger?
|
05-02-2016, 07:03 AM | #7 |
Gone Wild
Join Date: Dec 2013
Location: SE Louisiana
Posts: 257
|
Re: G29 charging, discharging, monitoring questions
DPI Accusense
http://www.cartsunlimited.net/battery-chargers.html Another thing.... 51.3 is full charge for you batteries, not 49.2. 49.2 is just above 60%, and almost dead. Do you have a digital voltmeter mounted on the cart, or just that junk bar gauge? If not, you need one asap. Below is some reading about state of charge for your batteries. http://www.buggiesgonewild.com/elect...rge-table.html How long have you had this cart? |
05-02-2016, 07:45 AM | #8 |
Not Yet Wild
Join Date: Apr 2016
Location: Drunken Slumber, Wisconsin
Posts: 33
|
Re: G29 charging, discharging, monitoring questions
Month and a half
|
05-02-2016, 04:02 PM | #9 | |
Not Yet Wild
Join Date: Apr 2016
Location: Drunken Slumber, Wisconsin
Posts: 33
|
Re: G29 charging, discharging, monitoring questions
Quote:
|
|
05-02-2016, 04:13 PM | #10 |
Gone Wild
Join Date: Dec 2013
Location: SE Louisiana
Posts: 257
|
Re: G29 charging, discharging, monitoring questions
Re-use you existing plug, or buy another to be used on the new charger.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
alltrax monitoring option???? | Electric EZGO | |||
Arduino Battery Monitoring. | Electric EZGO | |||
Motor power/voltage monitoring question | Electric EZGO | |||
Controller-Pro (Alltrax) data monitoring and logging. | Electric EZGO | |||
Battery monitoring | Electric Club Car |