|
|
|||||||
| Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
  |
|
|
Thread Tools | Display Modes |
08-09-2013, 06:31 AM
|
#11 |
|
Not Yet Wild
 Join Date: Dec 2007
Location: McDonough, GA
Posts: 29
|
Re: i have changed every part, and still no go g19E
I really thought you had an open battery.
Take the connections off (isolate) from the tow, throttle, main, and peddle stop switches and ohm them out, both ways. The controller must have those conditions met before it will work. |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
08-09-2013, 09:15 AM
|
#12 |
|
Gone Wild
Join Date: Feb 2012
Location: Indio, CA The Desert!
Posts: 1,263
|
Re: i have changed every part, and still no go g19E
ok, I will do that today, although I have been through every single wire many times over.
Today I will take each individual wire in the harness plug, pull it out of the harness, and squeeze it to make sure they are tight on the controller pins. That is the only thing I can think of that I have not did yet. I am doing this out of desperation. I have had this persons cart for 2 months now, trying to figure this out. I think after this, I will not work on anymore yamahas. |
|
|
|
|
08-18-2013, 06:27 PM
|
#13 |
|
Gone Wild
Join Date: Feb 2012
Location: Indio, CA The Desert!
Posts: 1,263
|
Re: i have changed every part, and still no go g19E
the problem ended up being the main 15 wire connector ( at the controller) was not seated tight enough. I found out when I would wiggle the connector, every once in awhile, it would make the solenoid click.
So I pushed real hard and even beat on the connector. and it finally started working. what a troubleshooting nightmare this was! thanks everyone that helped me  |
|
|
|
|
08-18-2013, 11:41 PM
|
#14 |
|
Gone Wild
Join Date: Jun 2013
Location: Atlanta Ga
Posts: 211
|
Re: i have changed every part, and still no go g19E
glad u got it fixed
|
|
|
|
|
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Has anyone changed a dcs fnr to a rocker switch... | Electric EZGO | |||
| Changed from a TXT to A PDS.... | Electric EZGO | |||
| Changed My Oil | Gas golf carts | |||
| changed my mind | Electric EZGO | |||
| Changed Cables /won't Run | Electric Club Car | |||
Linear Mode
