|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
04-11-2018, 03:16 PM | #1 |
Not Yet Wild
Join Date: Feb 2018
Location: Courtice Ontario
Posts: 18
|
Black sludge inside tailpipe??
Hello to everyone from Ontario where it snowed again today!
I am hoping that someone can shed some light on my old G2 which I know little about except that it was once on a golf cart . It is a 1988 according to the serial #. I’m freezing temps it starts right up and runs like a charm . After about 2 minutes of running I get the stinky blue smoke . The muffler is a used on that I bought from a person that was parting out their cart and he did tell me that his cart was running rich . Last night I was puttering on the cart and put my pinky finger into the tailpipe and was surprised with the oily sludge that came out . He pipe isn’t clogged but certainly coated .. I have read about 2 strokes gumming up a muffler but a 4 stroke ? With the fact that the cart starts up in the freezing cold I assuming compression is sufficient. It has only 1 qt of 10w30 royal purple synthetic in it and the air filter is clean . Is it possible that this sludge was in the muffler and it’s not my motor that has a problem ? Or what would be wrong with my motor to produce this in the muffler ? I’m reluctant to tear it down with how good it runs but am I harming it to run it ? It’s going to be a toy at the trailer park so not going to work like a dog . Do g2’s do this to mufflers ? Any thoughts would be appreciated . As always, thank you, Chris |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-11-2018, 09:19 PM | #2 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: Black sludge inside tailpipe??
If the cart it was previously on ran a long time with bad oil scrapper rings it's very well could have built up junk over the years take it off and BBQ it beings it dosnt smoke right away I bet after the two minutes of running the muffler gets hot enough to start burning off what's in the muffler
|
04-11-2018, 10:19 PM | #3 | |
Admin
Join Date: Dec 2006
Location: TN
Posts: 101,858
|
Re: Black sludge inside tailpipe??
Quote:
|
|
|
||
04-12-2018, 07:59 AM | #4 |
Not Yet Wild
Join Date: Feb 2018
Location: Courtice Ontario
Posts: 18
|
Re: Black sludge inside tailpipe??
Then a bbq it is !!
I will do a magnet test to make sure it isn’t aluminum ! Thx gents! |
|
|
Similar Threads | ||||
Thread | Forum | |||
sludge in crankcase | Gas Yamaha | |||
Oily sludge in vaccum line | Gas EZGO | |||
Tailpipe?? | Gas Yamaha | |||
Black Box Inside Engine | Gas EZGO | |||
EZ Go 2+2 Sport -- white smoke from tailpipe after flipping | Gas EZGO |