|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
11-11-2015, 07:41 PM | #1 |
Not Yet Wild
Join Date: Dec 2013
Posts: 6
|
04 club car ds wont move
a friend of mine brought me his cart to try and help figure out why it wont go anymore.its have an 04 ds. serial number starts with AQ0412 it worked fine before May of this year. his wife went to get on it the next day and would go anymore.
i have check all batteries and voltages vary between 7.4 and 7.6 volts. its a 48v system total voltage right now is 45 volts. i checked all the cables and they are good ( had to replace a few of them). i then followed the cables back to the solenoid and on both sides ( red and yellow cables on top of solenoid) the voltage is the same (45 volts). i was able to put it in reverse and while holding the pedal to the floor and giving a little push the cart would move about a foot then stop but will not do it in forward. the push i gave wasn't enough force to move the cart how do i check the other components to see if they are good. i have the cart on charge now and the meter on the charger has jumped over to 15 thanks for any advise |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-11-2015, 07:43 PM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,410
|
Re: 04 club car ds wont move
Hard to test it without proper voltage...... jack a wheel off the floor but even then..... put a meter on the pack and see how low the voltage goes when you press the gas.
|
11-11-2015, 08:01 PM | #3 |
Not Yet Wild
Join Date: Dec 2013
Posts: 6
|
Re: 04 club car ds wont move
i will try that. but what is proper voltage? should it read 48volts and each battery 8v?
|
11-11-2015, 08:30 PM | #4 |
Gone Wild
Join Date: Mar 2012
Location: Katy, Tx
Posts: 1,027
|
Re: 04 club car ds wont move
48v is 50% charged. After charge and a 12hr rest they should be 50.9 if memory serves me. Let them charge until charger shuts off. If it doesnt shut off after 16hrs then unplug it. Bad batteries could be a problem.
|
11-12-2015, 06:58 PM | #5 |
Not Yet Wild
Join Date: Dec 2013
Posts: 6
|
04 club car ds wont move
Update. Batteries are charged. Reading 50 volts. I have the rear up on jack stands. When pushing the pedal you can hear a click from the solenoid but tires don't move. If I spin tires with foot while pushing pedal the tires spin on their own but it's barely moving. Acts like it's not getting enough power to the motor. Is there a way I can test motor to see if controller is putting out enough power? I would almost think the motor has a burn spot on the armature or one of the leads isn't making good connection. I have used a meter and ohms all the big cables that I can and they check fine. You can tell the tires army spinning like they should and it somewhat of an on off sound from the motor. I checked voltage at green wire. A1 terminal and it read same as across the packs. And no change while tires are moving or sitting still
|
11-16-2015, 07:35 PM | #6 |
Not Yet Wild
Join Date: Dec 2013
Posts: 6
|
I figured out that the throttle pedal box under the cart must have a short in it. I took it out and used a screw driver to turn the mechanism and the tires started spinning fast but as I wiggle it they cut I and out. Looks like I need a new one
|
11-16-2015, 08:36 PM | #7 |
Gone Wild
Join Date: Mar 2012
Location: Katy, Tx
Posts: 1,027
|
Re: 04 club car ds wont move
Contact revolution golf carts so he can make sure you get the correct mcor
|
11-16-2015, 10:23 PM | #8 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 04 club car ds wont move
Thanks for the referral Epb....
The correct replacement part is a kit number AM293101. |
11-17-2015, 06:53 AM | #9 |
Not Yet Wild
Join Date: Dec 2013
Posts: 6
|
Thank yall for the help
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Club Car wont move | Electric Club Car | |||
96 Club Car - Wont move | Electric Club Car | |||
03 club car 48v wont move.... | Electric Club Car | |||
Club Car wont move | Gas Club Car | |||
club car wont move | Electric Club Car |