|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
04-01-2018, 12:52 PM | #11 | |
Not Yet Wild
Join Date: Oct 2017
Posts: 29
|
Re: 1986 G3 Forward Solenoid went bad
Quote:
|
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-01-2018, 03:33 PM | #12 |
Not Yet Wild
Join Date: Oct 2017
Posts: 29
|
Re: 1986 G3 Forward Solenoid went bad
Solenoid purchased. Carb soaking in Berrymans with the rebuild kit in the ready.
Drained fuel tank and installed new fuel filter. Put some oil in the cylinder and installed a new spark plug. |
04-01-2018, 06:16 PM | #13 |
Not Yet Wild
Join Date: Oct 2017
Posts: 29
|
Re: 1986 G3 Forward Solenoid went bad
Carb rebuilt, installed plug. Awaiting solenoid and ready to start it up.
|
04-01-2018, 07:00 PM | #14 | |
Gone Wild
Join Date: Jan 2017
Location: venice
Posts: 1,805
|
Re: 1986 G3 Forward Solenoid went bad
Quote:
did you try swapping the small wires on your old solenoids to see if it would crank both ways? heres a link to a g1 service manual which may help. if it uses the same engine and drive train i would assume the wiring would be the same. http://www.buggiesgonewild.com/garag...ir-manual.html also perform the starter generator test. Heres a link to one listed for the Harley 2 stroke carts but it is the same for the Yamaha 2 stroke as well. i like the visual on this and the test listed in the Yamaha section the picture no longer works. http://www.buggiesgonewild.com/gas-h...generator.html |
|
04-01-2018, 08:26 PM | #15 | |
Not Yet Wild
Join Date: Oct 2017
Posts: 29
|
Re: 1986 G3 Forward Solenoid went bad
Quote:
I'm not electrical saavy. I already ordered a 2nd solenoid. |
|
04-02-2018, 03:44 PM | #16 |
Gone Wild
Join Date: Jan 2017
Location: venice
Posts: 1,805
|
Re: 1986 G3 Forward Solenoid went bad
wait is your engine turning over both directions and just not starting in one direction?
|
04-02-2018, 03:50 PM | #17 | |
Not Yet Wild
Join Date: Oct 2017
Posts: 29
|
Re: 1986 G3 Forward Solenoid went bad
Quote:
Hence why I ventured into buying a new solenoid (Rodgers). The sellers webpage stated that I need to buy 2. I figured I could try and get it to work on 1 since only 1 is bad (forward). In one of my configurations on the new solenoid, the starter rolled forward in any position on the key "and" without touching the foot pedal. My assumptions are that the internals of the new solenoid are incompatible in working in conjunction with the old working (reverse) solenoid. |
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Solenoid not engaging with Forward / Reverse switch? (Solenoid is good) | Electric EZGO | |||
1986 club car gas won't shift lever won't go in forward | Gas Club Car | |||
1986 club car 36 volt goes fine in reverse but not in forward | Electric Club Car | |||
1986 parcar w/solenoid conversion wont charge | Gas Columbia ParCar | |||
1986 Club Car solenoid wiring diagram | Electric Club Car |