|
|
|||||||
| Electric Club Car Electric DS, and Precedent golf cars |
  |
|
|
Thread Tools | Display Modes |
03-17-2020, 07:46 PM
|
#11 |
|
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: 01 DS not charging
If you jumped the Black wire from the charge receptacle to pack negative then the OBC is not in the loop anymore and can probably be ruled out.
Make sure the Red wire from the receptacle goes to the pack main positive and make sure it is not corroded or burned where the connector is crimped on. If that is OK, check the Pack voltage while the charger is plugged in and running and see if the pack voltage is higher. Then check voltage of each battery individually while the charger is on and make sure voltage has increased on each one. |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
03-18-2020, 05:37 AM
|
#12 |
|
Gone Wild
Join Date: Oct 2008
Location: East Texas
Posts: 586
|
Re: 01 DS not charging
The batteries were low on water and I was trying to get them charged up before adding distilled water. After the second charger acted the same, I decided to go ahead and fill them up. It took 4 gallons!! Not much hope for these batteries, but I left it charging late yesterday and see what it looks like today. Thanks for the help!!
|
|
|
|
|
03-18-2020, 05:34 PM
|
#13 |
|
revolutiongolfcars.com
 Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 01 DS not charging
4 gallons? Mercy. Safe to say those batteries are done.
|
|
|
|
|
03-18-2020, 11:20 PM
|
#14 |
|
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 01 DS not charging
You will see a lot of Black film floating at the top of the plates. Pretty much tells you they burned up by being exposed while charging.
|
|
|
|
|
03-21-2020, 08:06 AM
|
#15 |
|
Gone Wild
Join Date: Oct 2008
Location: East Texas
Posts: 586
|
Re: 01 DS not charging
Just as we thought, batteries are toast. Four full charge cycles and didn't get up to 49 volts 12 hours after cycle completed.
|
|
|
|
|
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| 2014 Club Car ERIC charging cart not charging | Electric Club Car | |||
| 2014 CC Precedent w/ Eric charging system and charger is flashing and not charging.. | Electric Club Car | |||
| 1997 electric 48v club car charging not charging my batteries? | Electric Club Car | |||
| 2006 TXT 20+amps but not charging, hot charging cable | Electric EZGO | |||
| Battery Charging Question (How to keep from over-charging) | Electric EZGO | |||
Linear Mode
