|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
07-17-2011, 03:05 PM | #1 |
Not Yet Wild
Join Date: Jul 2011
Location: jupiter fl
Posts: 7
|
workhorse will not turn over
Hey folks. I am looking for some help getting an workhorse project off the ground. It is a 99 workhorse with the 350 robin engine. My issue is the cart will not turn over to start. I have connected cables to the starter and turned it over fine. I started tracking the down the voltage and it ends at the solinoid. When the gas pedal is depressed I get voltage from the key switch to the solinoid but the starter side of the solinoid does not get hot. I replaced the solinoid and the condition is the same. Is there a place to view an ignition schematic? Thanks for any advice as I am new to carts.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-17-2011, 04:55 PM | #2 |
Not Yet Wild
Join Date: Apr 2011
Location: Friendswood, TX
Posts: 27
|
Re: workhorse will not turn over
Does the solenoid make a noise. If it does not then check the ground or negative side of the solenoid secondary cuircut. If there is no ground wire, the solenoid could be ground to itself and then to the frame. Use ohm meter to check continuity from negative post on battery to base of solenoid or opposite post from microswitch power wire. Should be very low ohms. If it is making a noise when energized, then disconnect the large primary wire from battery and ohm across large terminals. When pedal is depressed you should get the clicking noise and the ohm reading should go low, showing a connection. I'll bet on a bad or dirty ground.
|
07-17-2011, 05:11 PM | #3 |
Not Yet Wild
Join Date: Jul 2011
Location: jupiter fl
Posts: 7
|
Re: workhorse will not turn over
Bingo! It was a ground issue. the support bracket has rusted away not allowing a good ground. I was able to put a jumper on what is left of the bracket and was able to turn it over and get spark. next task clean up fuel system and get a pop. Thank You!!!!!!!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
It won't turn off!!! HELP!!! | Gas EZGO | |||
1999 workhorse 1200 or 2006 workhorse 800, which one? | Gas EZGO | |||
85 ez-go won't turn over | Gas EZGO | |||
Wont turn left and now wont turn right | Electric EZGO | |||
G16 don't turn off | Gas Yamaha |