|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
06-08-2009, 09:25 AM | #1 |
Not Yet Wild
Join Date: Jun 2009
Posts: 5
|
Where is solenoid on 99 Ez Go?
Hi folks. I am new to golf carting. When I purchased my house the owner sold me the ez go electric golf cart that he used at the property for hopefully a very good price. I have ridden it around some and enjoy it greatly.
The problem is that it now seems not to want to run. (Actually, it will run sometimes, but most of the time it won't.) When I put it in reverse I get a strong "back-up" beep. When I depress the accelerator pedal I hear a clicking sound, but get no movement. I'm assuming I've got a solenoid problem, but I'd appreciate it if someone would confirm that. Also, I took the seat off and looked in the battery compartment. I didn't see a solenoid there. Is it possible that the solenoid is in the rear, right next to the electric motor? If not, where is it? I think my cart is a 1999 Ez Go, but not positive. It is 36V, since it has six 6V batteries. Anyone have any idea what's wrong, and where is the solenoid? How can I check to see that the solenoid is the problem? Thanks! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-08-2009, 10:20 AM | #2 |
Gone Wild
Join Date: Mar 2009
Location: Roseville, CA
Posts: 2,757
|
Re: Where is solenoid on 99 Ez Go?
The solenoid should be between the controller and the F-N-R switch. Silver colored with 2 large posts and 2 small posts.
|
06-08-2009, 10:39 AM | #3 |
Not Yet Wild
Join Date: Jun 2009
Posts: 5
|
Re: Where is solenoid on 99 Ez Go?
Thank you!
I'm pretty sure I'd know the solenoid if I saw it -- I've replaced one on a car before. I just don't know what part of the vehicle body I need to remove to get to it on the golf cart. I know where the F-N-R switch is, but not sure I can identify the controller. There is something that may be a controller on the passenger side, under the seat next to the batteries, that appears to be mounted along the wall. From memory, it seems to be about 4" x 6" x 12" or so. If that's not the controller, then I guess it must be located in the rear next to the electric motor. I did take look under an area with wires that is in between the F-N-R switch and what I described above as the probable controller, but I did not see anything that resembled a solenoid. This was mounted against the passenger wall between the FNR and controller, so it would seem to be in the correct location. As I recall, the space was very tight there and I couldn't see everything, so if the solenoid is very small on a golf cart, perhaps it's in that area after all. If you think that's where it's located, I'll get a flashlight and look again. Thanks for your help! |
06-08-2009, 10:44 AM | #4 |
steeplejack x
Join Date: Jan 2007
Location: Republic of Texas
Posts: 3,382
|
Re: Where is solenoid on 99 Ez Go?
Look under the controller environmental cover. You'll likely find the solenoid there.
Is there a Run/Tow Maintenance switch on the controller cover? If yes, then you have a DCS cart so be very sure to switch to tow before doing any maintenance on the cart. Low battery voltages can also be suspect. Good luck. |
06-08-2009, 10:51 AM | #5 |
Gone Wild
Join Date: Mar 2009
Location: Roseville, CA
Posts: 2,757
|
Re: Where is solenoid on 99 Ez Go?
Here is a photo of my cart, under the seat, passenger side. Yours may not be the same but should be similar.
The controller on the left, F-N-R switch on the right and solenoid bottom center. http://i232.photobucket.com/albums/e...t/P4280188.jpg |
|
|
Similar Threads | ||||
Thread | Forum | |||
solenoid help | Electric Yamaha | |||
HD Solenoid | Electric Club Car | |||
solenoid | Electric Yamaha | |||
J14 Solenoid | Electric Yamaha | |||
If its not the solenoid?..... | Electric EZGO |