|
|
|||||||
| Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
  |
|
|
Thread Tools | Display Modes |
03-29-2017, 10:08 AM
|
#1 |
|
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
G5 sun classic always turns over
Friend brought me a g5 it continuously turns over regardless of key position and throttle position only way to stop it is unhook the battery that being said checked microswitch at peddle it checked out and so did starter solenoid does this mean voltage regulator is junk?
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
03-29-2017, 10:17 AM
|
#2 |
|
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: G5 sun classic always turns over
Also get twelve volts to solenoid "signal wires" all time but if I unhook voltage regulator it stops
|
|
|
|
|
03-29-2017, 03:43 PM
|
#3 |
|
Gone Wild
Join Date: May 2011
Location: Pittsburgh
Posts: 2,950
|
Re: G5 sun classic always turns over
Without knowing that specific cart, to my knowledge VRs only serve to keep the starter / gens in check by making sure they aren't putting putting out too much current to hurt things while allowing enough to keep the battery charged. I don't know any of them to have anything to do with the starter circuit but, again, I don't that cart.
I actually would start with the key switch or the wiring associated with it. |
|
|
|
|
03-29-2017, 04:08 PM
|
#4 |
|
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: G5 sun classic always turns over
I'd agree with you on other carts but this one is a little unique compared to other Yamaha's has six pins coming out of voltage regulator one of witch is a signal wire to activate the starter solenoid
|
|
|
|
|
03-29-2017, 05:25 PM
|
#5 |
|
Gone Wild
Join Date: May 2011
Location: Pittsburgh
Posts: 2,950
|
Re: G5 sun classic always turns over
Roger that. There is always something new to learn with these carts.
|
|
|
|
|
03-29-2017, 06:52 PM
|
#6 |
|
Sometime's............
 Join Date: Oct 2007
Location: Tacoma Washington
Posts: 11,875
|
Re: G5 sun classic always turns over
Yes, on a G5-a the starting circuit does run thru the AVR. As I recall, CGtech had a wireing diagram to install a standard AVR, like out of a G16-a.
|
|
|
|
|
03-29-2017, 09:42 PM
|
#7 |
|
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: G5 sun classic always turns over
Yes he did small block I found that just wanted to make sure before I ordered a new voltage regulator v
|
|
|
|
|
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| sun classic g5 | Gas Yamaha | |||
| G1 Turns over with key off | Gas Yamaha | |||
| Bad Boy Classic | Electric golf carts | |||
| G1 turns over, but won't go! | Gas Yamaha | |||
| '85 G1 turns over ... | Gas Yamaha | |||
Linear Mode
