|
|
|||||||
| Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
  |
|
|
Thread Tools | Display Modes |
03-31-2016, 10:45 AM
|
#1 |
|
Not Yet Wild
Join Date: Mar 2008
Location: sw Ohio
Posts: 19
|
Carb spitting gas out the inllet
86 G1 gas
new bore,piston ,-rings, top bearing,gaskets The problem I have is gas spits out the inlet of the carb. before and after rebore. I checked the muffle and BBQ it. I cleaned the reed valve and they look good now ----BUT they are made with a small step at the base where the valve and the other plate screws to the housing. There is an air gap there at the base , it seems like this should not be there. The motor is hard to start usually , when it runs, it feels good for a while ,then it gets weak and quits, wont restart until it cools off. I am waiting on a new reed valve ,,but I not sure about the gap at the bottom of the housing of the reed valve holder. What else could be the problem!!! |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
03-31-2016, 05:16 PM
|
#2 |
|
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: Carb spitting gas out the inllet
usually two stroke spitting gas out carb is bad reeds
|
|
|
|
|
03-31-2016, 09:21 PM
|
#3 |
|
Not Yet Wild
Join Date: Mar 2008
Location: sw Ohio
Posts: 19
|
Re: Carb spitting gas out the inllet
Thanks
I ll let you know if new reeds does it What do you think about the reed housing having a step at the bottom near the screws, that has a small air gap where the valve meets the housing? This is my frist reed valve project involvement and the videos all say they should be flush. |
|
|
|
|
03-31-2016, 09:41 PM
|
#4 |
|
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: Carb spitting gas out the inllet
i guess Im having a hard time visualizing what you're saying can you post pictures of it?
|
|
|
|
|
03-31-2016, 09:52 PM
|
#5 |
|
Not Yet Wild
Join Date: Mar 2008
Location: sw Ohio
Posts: 19
|
Re: Carb spitting gas out the inllet
Yes
Maybe tomorrow |
|
|
|
|
| Tags |
| reed valve questions |
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| gas is spitting come out carb | Gas Columbia ParCar | |||
| 1991 ezgo spitting gas out carb into air filter | Gas EZGO | |||
| 97 ezgo spitting gas out of the carb | Gas EZGO | |||
| 4 stroke - spitting gas thru carb - the finale! | Gas EZGO | |||
| Fuel spitting out of carb and into aircleaner | Gas Club Car | |||
Linear Mode
