04-25-2019, 08:13 PM | #1 |
Not Yet Wild
Join Date: Apr 2010
Posts: 29
|
2003 CCDS Won't Crank
Hello. I have a 2003 DS that won't crank. If I put power to the blue wire on the solenoid, and push the pedal, it will start normally. It will run if I remove power from the blue wire, but will not start again until power is reapplied to that terminal again. Any ideas? Where does the blue wire get its power from? Thanks.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-25-2019, 08:28 PM | #2 |
Gone Wild
Join Date: Oct 2009
Location: Lee County, Georgia
Posts: 521
|
Re: 2003 CCDS Won't Crank
Check the fuse in the black electrical box on the drivers side under the seat. If that is OK your ignition switch may need testing/replacing.
|
04-25-2019, 08:41 PM | #3 |
Not Yet Wild
Join Date: Apr 2010
Posts: 29
|
Re: 2003 CCDS Won't Crank
That fuse was blown. Replaced it. Didn't blow again. Still same result. I'm pretty sure that I tested all of the terminals on the key switch, and none of them were hot. It's at my shop, so I cant do it now. Thanks for the reply.
|
04-25-2019, 10:22 PM | #4 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,813
|
Re: 2003 CCDS Won't Crank
Jimmie is right though about the ignition switch needing testing. That IS were the blue wire gets power. Back track from there. I know you replaced the fuse, but did you check for power to & through the fuse?
http://www.buggiesgonewild.com/gas-c...iagrams-2.html |
04-30-2019, 02:17 PM | #5 |
Not Yet Wild
Join Date: Apr 2010
Posts: 29
|
Re: 2003 CCDS Won't Crank
It has no power at the key switch. It has one fuse in the fuse block and it is good (has power on both sides). The fuse in the yellow fuse holder is good and has power. I was going to now check the red wire that goes to the key switch.
|
05-07-2019, 02:25 PM | #6 |
Not Yet Wild
Join Date: Apr 2010
Posts: 29
|
Re: 2003 CCDS Won't Crank
Thanks for the info, and the diagram.
|
05-07-2019, 02:26 PM | #7 |
Not Yet Wild
Join Date: Apr 2010
Posts: 29
|
Re: 2003 CCDS Won't Crank
Someone put a hidden remote switch on the red wire.
|
05-07-2019, 03:49 PM | #8 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,813
|
Re: 2003 CCDS Won't Crank
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
99 CCDS over charging?? | Gas Club Car | |||
2003 ccds no torque? | Electric Club Car | |||
36v ccds | Electric Club Car | |||
aligment of cam shaft, crank, and crank balance on g14 | Gas Yamaha | |||
91 CCds runs with key off or on | Electric Club Car |