|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
04-17-2020, 09:22 PM | #1 |
Not Yet Wild
Join Date: Apr 2020
Posts: 4
|
After half throttle
I have a 1993 Yamaha g9, the problem I have having I after half throttle it just falls on its face and goes back to intial start up I can then push pedal back down to half throttle and runs perfectly but once it goes past half it just stops again, any help on this would be highly appreciated. I've put on a new pulsar coil due to the wires being melted
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-18-2020, 03:40 AM | #2 |
Runs with scissors-
Join Date: Dec 2010
Location: Da UP
Posts: 1,962
|
Re: After half throttle
Welcome!
Does it run at all after the half-throttle point? For instance spit & sputter, or backfire? Could be fuel - check fuel filter, lines, pump. Haven’t run into problems with the pedal switch cutting out like that, but that seems like a possibility. |
04-18-2020, 07:58 AM | #3 |
Not Yet Wild
Join Date: Apr 2020
Posts: 4
|
Re: After half throttle
It tries when I feather the choke
|
04-18-2020, 08:00 AM | #4 |
Not Yet Wild
Join Date: Apr 2020
Posts: 4
|
Re: After half throttle
Should have added that I pulled the tank, changed the filter added a inline filter and replaced the fuel pump
|
04-18-2020, 08:22 AM | #5 |
Not Yet Wild
Join Date: Apr 2020
Posts: 32
|
Re: After half throttle
i do lots of motorcycle and atv gas work.
it sounds like its starving for fuel, will the engine rev without a load on it? Will it rev high with the choke on? if it sputters after idle when moving into mid range, the pilot jet/ emulsion tub in the carb is clogged easy fix walt |
04-18-2020, 08:43 AM | #6 | |
Runs with scissors-
Join Date: Dec 2010
Location: Da UP
Posts: 1,962
|
Re: After half throttle
Quote:
|
|
04-18-2020, 09:23 AM | #7 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,682
|
Re: After half throttle
Before going in circles, chasing things down, make 1000% sure the airbox lid is COMPLETELY sealed. If even one of those rubber band things is off or broken it will run like that.
Zip ties work well to replace broken rubber bands |
04-19-2020, 08:23 PM | #8 |
Not Yet Wild
Join Date: Apr 2020
Posts: 4
|
Re: After half throttle
Repaired damaged airbox, cleaned carburetor thoroughly runs a little bit better thinking of getting a new air box .gorilla tape can only go so far, thank you for the insightful information highly appreciated
|
04-19-2020, 09:03 PM | #9 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,682
|
Re: After half throttle
On my G2 my kids hit a branch and cracked the airbox where the front mount clips in. Ran awful. These carts are very specifically tuned to run on the complete OEM airbox. Any little air leaks make a huge difference.
|
04-21-2020, 07:37 AM | #10 |
Out to Lunch
Join Date: Oct 2019
Location: Houston, TX
Posts: 451
|
Re: After half throttle
^^^^^ Is there a way to count the number of times you have posted that same thing? It should be a sticky....... Things to check first if your cart is running poorly!
KKJ, I saw new air box assemblies on e-bay in various stages of completeness. Depending on how bad yours is in you could probably grab one of the cheaper options (still not cheap) and piece yours back together. https://www.ebay.com/itm/Yamaha-Golf...AAAOSw3v5XIltO https://www.ebay.com/itm/Yamaha-Golf...AAAOSwImRYHTQg https://www.ebay.com/itm/Yamaha-Golf...QAAOSwXeJYHTWU |
|
|
Similar Threads | ||||
Thread | Forum | |||
Only run at half throttle | Gas Yamaha | |||
yamaha g2 bogs at half throttle through full throttle | Gas Yamaha | |||
Bog out after half throttle? | Gas Yamaha | |||
Half throttle only | Electric Yamaha | |||
Full throttle, Half throttle????? | Electric EZGO |