|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
07-05-2017, 05:39 PM | #1 |
Not Yet Wild
Join Date: Jul 2017
Posts: 13
|
97 has spark, fuel, compression, air but won't start
I have a 'new to me' cart that has been running great then all of a sudden it just stopped. I was driving through some tall brush the other day, but normally it's just driven on grass.
I turn the key to on, press the pedal and the engine spins, the air passage is clear, the fuel pump works, the spark plug is sparking and I have compression. I even tried using starting fluid, but no luck. It acts like there is a kill switch that is preventing it from starting. Thanks for your help! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-05-2017, 05:45 PM | #2 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 97 has spark, fuel, compression, air but won't start
If spark plug is sparking, there is no kill switch.
|
07-05-2017, 06:54 PM | #3 |
Gone Wild
Join Date: May 2015
Location: Central Florida
Posts: 2,114
|
Re: 97 has spark, fuel, compression, air but won't start
If its not starting on starter fluid, your missing either spark or compression. Double check those
|
07-05-2017, 08:26 PM | #4 |
Not Yet Wild
Join Date: Jul 2017
Posts: 13
|
Re: 97 has spark, fuel, compression, air but won't start
With the key in the ON position:I pulled the plug then pressed the pedal, the motor spins and it shows a spark. [/LIST]I pulled the hose from the carb to filter and put my hand over the opening then pressed the pedal and can feel the compression. [/LIST]I pulled the fuel hose from the carb to the pump then pressed the pedal and gas pumps out.
It acts exactly like when I try to start my tractor in the OFF position... my tractor starter will still crank the motor but it won't allow it to run. I did see a double wire with a connector on the end not plugged into anything under the motor. |
07-05-2017, 08:58 PM | #5 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 97 has spark, fuel, compression, air but won't start
Do you have another plug to try. Sometimes they spark outside but not under compression.
|
07-05-2017, 10:05 PM | #6 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: 97 has spark, fuel, compression, air but won't start
"I pulled the hose from the carb to filter and put my hand over the opening then pressed the pedal and can feel the compression." Yyeeaaahhh nooo that's not how you check compression rent/barrow a compression tester and report back with the results
|
07-06-2017, 02:35 AM | #7 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 97 has spark, fuel, compression, air but won't start
Are you checking compression in the plug hole?
|
07-06-2017, 05:36 AM | #8 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,823
|
Re: 97 has spark, fuel, compression, air but won't start
Do a quick check under the valve cover. Make sure the push rods are in place and the valves open & close as you turn the motor by hand. You could still have "suck & push" at the carb with stuck valves.
|
07-06-2017, 07:13 AM | #9 |
Not Yet Wild
Join Date: Jun 2017
Location: Urbana, IA
Posts: 64
|
Re: 97 has spark, fuel, compression, air but won't start
+1. Unless your a mechanical god, I'd bet the farm you can't tell the difference between 20psi and 120psi using your method. This could make a huge difference. You've diagnosed that you have SOME compression, but is it nearly enough? Only a compression gauge in the plug holes will tell you.
|
07-06-2017, 09:26 PM | #10 |
Not Yet Wild
Join Date: Jul 2017
Posts: 13
|
Re: 97 has spark, fuel, compression, air but won't start
Tried a new spark plug, but no start. Will try to check compression and report back.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Spark, fuel & compression but won't start | Gas Club Car | |||
Fuel, spark, compression wont fire..hmmm half way fixed | Gas EZGO | |||
Yamaha G2 spark fuel compression will not start please help!!! | Gas Yamaha | |||
G9 No start, fuel, no spark | Gas Yamaha | |||
Fuel, compression, and spark questions | Gas EZGO |