|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-08-2013, 08:18 PM | #1 |
Not Yet Wild
Join Date: Jan 2013
Location: Nova Scotia
Posts: 31
|
2001 CC DS new build but engine not running properly
Been a long two weeks but finally finished my 2001 CC DS. But cart runs rough and backfires on occasion. Also smells like its burning rich. Cart also lacks power on hills. I had clutch machined by Tom @ CCP with new belt and 200 rpm spring. During the build I replaced the carb with a new one. Also I had 1/4" of fuel in the air box. When I replaced the plug it was black as night. Wish it ran as good as it looks. Any help would be appreciated
New camo wrap Beefed up springs 6" jakes drop spindle lift 12" Vegas Machined rims 23" Duro Tires fender flares flip flop seat light kit bush bar folding windshield panoramic rear view mirror new fuel lines and filter new fuel pump pulse line new carb new air flter machined clutch 200 rpm spring new belt new oil and filter changed rear end oil cleaned entire frame with alumabright while disassembled |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-08-2013, 09:58 PM | #2 |
Gone Wild
Join Date: Aug 2009
Location: Eldon Missouri
Posts: 977
|
Re: 2001 CC DS new build but engine not running properly
Have you tried adjusting the A/ F screw to set your mixture correctly ? It looks like you have thrown the kitchen sink at your cart but a new carb is rarely correct out of the box. This isn't a Christmas tree pal. Glitter and lights aren't enough if you can't power them up. Start off with 1 1/2 turns off of just seated and adjust 1/4 turn out until the cart begins to respond properly on a warm engine. Assuming all other parameters are set right this should get you close or exactly where you want to be.
Hope that helps and please let us know the results. Chris. |
08-08-2013, 11:38 PM | #3 |
Not Yet Wild
Join Date: Jan 2013
Location: Nova Scotia
Posts: 31
|
Re: 2001 CC DS new build but engine not running properly
Yes lol I did put alot into it. The cart seemed to work ok when I bought it but I only drove it for one weekend before tearing it apart. Yes I was thinking about setting the pilot screw on the carb but wasn't sure if they came pre set. But I don't think that would explain my lack of power on hills though???? One step at a time!
Thanks |
08-09-2013, 08:31 PM | #4 |
Not Yet Wild
Join Date: Jan 2013
Location: Nova Scotia
Posts: 31
|
Re: 2001 CC DS new build but engine not running properly
Well it turns our that the new carb that I bought was missing the small led plug between the Pilot Jet and the Pilot Air Screw. Witch allowed dirt to be sucked in to the Pilot Jet chamber causing the cart to burn rich. Good thing I kept the old carb. Put it back on, cleaned the fowled plug, fine tuned the Pilot Air Screw. Works like a top now. Runs smooth now and lots of power, no problem climbing hills with a cart load of people.
Just going to change the oil again to make sure no fuel got into the crank case. For the sake of a few bucks gives me the piece of mind. Smelled the dipstick seemed ok..... pulling the steering collum out tomorrow so I can install my new carbon fiber dash. Any tips on pulling it out and installing these aftermarket dashes???????????? |
08-09-2013, 11:33 PM | #5 |
Gone Wild
Join Date: Aug 2009
Location: Eldon Missouri
Posts: 977
|
Re: 2001 CC DS new build but engine not running properly
The new dash should instal easily once you get the steering wheel off and that can be a nuisance. Figure on releasing the centre nut and then having a Gorilla pulling back on the wheel while you clout it mightily with a large rubber mallet. They can be a royal pita to remove.
Chris. |
08-10-2013, 01:53 PM | #6 |
Not Yet Wild
Join Date: Jan 2013
Location: Nova Scotia
Posts: 31
|
Re: 2001 CC DS new build but engine not running properly
tried that already for two days. bent 3/8 plate with my puller. Even used PB Blaster. So now i have just removed the whole colum.
|
08-10-2013, 08:37 PM | #7 | |
Gone Wild
Join Date: Aug 2009
Location: Eldon Missouri
Posts: 977
|
Re: 2001 CC DS new build but engine not running properly
Quote:
Bloody ridiculous isn't it ? I've pulled clutches and swapped engines out faster than a simple steering wheel swap. It's not like you can us a regular puller either. I beat up one last week until I was sure I would damage the lower U-Joint. It's just a simple spline connection ffs. I adjusted my bike rear brake lever this afternoon; TWO ******* minutes easy. Same system and mechanics. Club Cars are a joke sometimes. Chris. |
|
08-12-2013, 07:40 AM | #8 |
Getting Wild
Join Date: Sep 2012
Location: Tennessee
Posts: 94
|
Re: 2001 CC DS new build but engine not running properly
Loosen the steering wheel nut, but do NOT remove it!! After endless beating and pulling on the steering wheel, when it decides to let go, it does so quickly and without warning. Without that nut in place to "catch" it, you're looking at a BAD day.
http://www.buggiesgonewild.com/lifte...l-removal.html |
|
|
Similar Threads | ||||
Thread | Forum | |||
2001 CC Gas Keeps Running after a Stop | Gas Club Car | |||
My EZGO 600CC F4 BUILD GOT THE ENGINE RUNNING GOOD | Bike & ATV Engine Swaps | |||
84 marathon back firing and not running properly | Gas EZGO | |||
Robin EC25-2PG not running properly. | Gas EZGO | |||
2001 Elec EZ Go TXT Intermittent Running | Electric EZGO |