|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
05-12-2015, 04:06 PM | #11 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,141
|
Re: 2002 EZGO TXT dies after 20 minutes.
May also have a plugged vent in the fuel tank.. Cart will run fine till it gets enough vacuum in the tank to starve the fuel pump.. Try loosening the fuel cap next time it happens and see if you hear that whoosh noise..
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-12-2015, 04:57 PM | #12 |
Gone Wild
Join Date: Apr 2015
Posts: 256
|
Re: 2002 EZGO TXT dies after 20 minutes.
Fuel cap sounds like a big possibility.
Another would be the solenoid. Hook up a test light to the output switched side and lay it where you can see it. Ride it around and see if the lite flickers or goes out when it dies. Next would be the ignitor. Hot to the touch says its bad. Do the hei mod and use your new coil you already have. If you want a hotter spark replace the coil with an hei nova coil. The pulsor coil will change ohms based on heat. that is normal. |
05-12-2015, 10:21 PM | #13 |
Not Yet Wild
Join Date: Apr 2015
Location: River Ranch, FL
Posts: 22
|
Re: 2002 EZGO TXT dies after 20 minutes.
I have not adjusted the valves. Will try the fuel cap thing asap.
|
05-12-2015, 10:58 PM | #14 |
It ain't gonna be easy.
Join Date: Apr 2008
Location: St. George, SC
Posts: 1,480
|
Re: 2002 EZGO TXT dies after 20 minutes.
Ok, good luck
|
05-14-2015, 08:25 AM | #15 |
Not Yet Wild
Join Date: Apr 2015
Location: River Ranch, FL
Posts: 22
|
Re: 2002 EZGO TXT dies after 20 minutes.
Ok, so yesterday I filled the tank and put the cap on very loose. Went for a ride and things were great! Cart ran great and we went for about 45 minutes, Engine got very warm. I just told my girlfriend I could not believe it was only the gas cap.
Then it died in the same way it has been.........back to the drawing board. I almost bought that Pulser Coil, but now I am not sure that is the problem either. |
05-14-2015, 10:00 AM | #16 |
It ain't gonna be easy.
Join Date: Apr 2008
Location: St. George, SC
Posts: 1,480
|
Re: 2002 EZGO TXT dies after 20 minutes.
Ok, can you recap, in detail what all you have done so far. Just RE reading this thread and want to see where we are at.
|
05-14-2015, 11:20 AM | #17 |
Not Yet Wild
Join Date: Apr 2015
Location: River Ranch, FL
Posts: 22
|
Re: 2002 EZGO TXT dies after 20 minutes.
Ok, all my issues started when my coil failed.
I got a new coil, it w bad out of the box, got a second new coil. Removed carb and cleaned it, was not very dirty. Replaced fuel lines with clear lines to see fuel flow. Put new spark plugs of the proper specs and gap in. Tested new coil to make sure it was in range, tested good. Tested Pulser coil to make sure it was in range. In range when cool, slightly out of range when hot. Rode around with loose gas cap. |
05-14-2015, 11:33 AM | #18 |
Gone Wild
Join Date: Jan 2015
Location: Kerrville, Texas
Posts: 162
|
Re: 2002 EZGO TXT dies after 20 minutes.
Maybe the clear fuel line has started collapsing due to the gas cap not venting?
|
05-14-2015, 12:49 PM | #19 |
Not Yet Wild
Join Date: Apr 2015
Location: River Ranch, FL
Posts: 22
|
Re: 2002 EZGO TXT dies after 20 minutes.
Actually the clear line has become more solid since having the gas running through it. I dont think that is happening. I had thought the same at first and when it happens I would hop off and check it. The always seems ok and has a good amount of fuel in it.
|
05-14-2015, 02:04 PM | #20 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,406
|
Re: 2002 EZGO TXT dies after 20 minutes.
Adjust valves = It simple/ easy/ and critical. Out of adjustment valves can cause excessive heat which screws with electronics. Also it sounds like the tank venting helped some but may not be your only problem. Replace the engine crankcase to fuel pump vacuum tube and put fresh fuel lines on it if you haven't already ... I would adjust valves and check oil level before one more ride.
Specs .004 cold in and out if I remember right |
|
|
Similar Threads | ||||
Thread | Forum | |||
2002 episodic dogging and dies | Gas EZGO | |||
pds drive ezgo shuts off after 15-20 minutes of continual use | Electric EZGO | |||
2008 EZGO RXV Died in Minutes of Driving. Very frustrated. | Electric EZGO | |||
Cart dies....but goes fine after it sits a few minutes. | Electric EZGO | |||
88 gas cc dies after running 20 minutes | Gas Club Car |