|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
07-07-2016, 01:41 PM | #1 |
Not Yet Wild
Join Date: Apr 2016
Posts: 40
|
G22 Won't turn off
We have this cart that we use to pick balls on the range that starting acting funny. Only after it warms up for a bit it will keep running after letting of the gas and stopping. It will just sit there and putter. It keeps doing it if you turn the key off too. It usually quits after a minute or so, or if you mess with the gas and choke it may stop after a while of trying. If it's acting up and you turn the key off it will move if you press the gas. Once it finally stops, it wont move until you turn the key on. I replaced the stop switch for the gas pedal and the solenoid.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-08-2016, 04:53 PM | #2 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: G22 Won't turn off
voltage regulator. unplug it and try again. dont drive too far. or unplug it while the cart is stuck cranking (be careful of spinning parts, runaway cart , ect.)
|
09-18-2018, 04:56 PM | #3 |
Not Yet Wild
Join Date: Jul 2018
Location: Dallas, TX
Posts: 11
|
Re: G22 Won't turn off
Hi. I have the same issue with my 2003 g22a. Starts great, Run strong but won't turn off when the key is switched off. The key must be on to start it, but won't turn it off. Appreciate any help.
|
09-19-2018, 11:50 AM | #4 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: G22 Won't turn off
I think your ignition kill relay has failed, in combination with a carb butterfly that is adjusted too far open. I am not talking about the main relay, this relay is much smaller (but located under the same black cover on the driver's side under the seat). I'll post the part number in a minute.
4U8-81950-02-00 RELAY ASSY |
10-03-2018, 05:47 PM | #5 |
Not Yet Wild
Join Date: Jul 2018
Location: Dallas, TX
Posts: 11
|
Re: G22 Won't turn off
Is there a way to test the relay before buying a new one?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
G2 will not turn over | Gas Yamaha | |||
won't turn over right away when hot | Gas EZGO | |||
Won't turn over | Gas Club Car | |||
It won't turn off!!! HELP!!! | Gas EZGO | |||
Wont turn left and now wont turn right | Electric EZGO |