|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
05-25-2014, 02:12 AM | #1 |
Not Yet Wild
Join Date: May 2014
Posts: 3
|
'95 model cuts out and restarts while driving
Morning all. A friend asked me to look at a 95 model (AG9546 on the ID plate) for him because when driving along, it will cut power intermittently and return to idle for a few seconds. If the gas pedal is held down, it will pick up again and continue driving for a short while before doing it again.
Does anyone have any pointers to what it could be please? It seems like a fuelling issue but the filter is always full (he drove while I observed the engine with the seat removed). Any help would be much appreciated. Thanks Mitch. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-27-2014, 01:39 PM | #2 |
Not Yet Wild
Join Date: May 2014
Posts: 3
|
Re: '95 model cuts out and restarts while driving
If no one has any suggestions, are there any troubleshooting manuals available?
|
05-27-2014, 02:11 PM | #3 |
Gone Wild
Join Date: Apr 2014
Location: dallas tx
Posts: 185
|
Re: '95 model cuts out and restarts while driving
Does it do it at high Rpms. Could be the rev limiter kicking in. It will shut down the engine for about 2 to 3 seconds. I think it kicks in around 4300
|
05-27-2014, 08:39 PM | #4 |
Getting Wild
Join Date: Sep 2011
Location: Liberty, MS
Posts: 108
|
Re: '95 model cuts out and restarts while driving
Check the vent on the carb. It's next to the adjustment screw....a little silver nipple. It normally has a plastic tube going from from to the it. I had a cart doing something similar and when I pulled the tube off, it ran great. Plug it up, it ran bad. Took my air hose and blew out the plastic line. Something came out! Plugged back up and ran fine.
Had the same issue with another cart, but it had no tube connected. Took some carb cleaner with the straw on it and stuck it in the little hole. Blew it out and runs fine now. If neither of those are the issue, I agree with previous post.....rev limiter. |
06-04-2014, 08:14 PM | #5 |
Not Yet Wild
Join Date: Mar 2009
Posts: 29
|
Re: '95 model cuts out and restarts while driving
just had one today that did this, it was a bad rpm limiter. You can start it in service mode and pull / unplug the first connector in line on the rpm limiter and if the cart doesn't shut off its likely the problem
|
06-05-2014, 12:19 AM | #6 |
Not Yet Wild
Join Date: May 2014
Posts: 3
|
Re: '95 model cuts out and restarts while driving
Thanks very much for the suggestions, I'll take a look when I get back home in a couple of weeks.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Throttle cuts out while driving | Electric Club Car | |||
90 ParCar cuts out while driving | Gas Columbia ParCar | |||
96 Cuts out when hot | Gas Club Car | |||
g2a cuts out at 19 mph | Gas Yamaha | |||
93 Gas..Runs good, then won't restart, wait a while and restarts | Gas Club Car |