|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
06-24-2020, 10:25 AM | #1 |
Not Yet Wild
Join Date: May 2019
Posts: 21
|
2005 carryall cafe express fe350 turns over sometimes also looking for cheap lift kit
2005 express cafe with the coffee shop removed
Fe350 motor New brushes New solenoid New battery - 675 cranking amps New starter belt New plug New air filter New carb, fuel pump and filter Fresh oil change with full synthetic and filter At times it will struggle to turn over to start. I can tap the pedal a bunch of times and sometimes it will go ahead or I can roll it forward or backwards just a little and it will start right up. Starter belt is tight enough to twist with 2 fingers about 25% which I had read in a lot of places to try. Almost like it has too much compression to turn at times. At this point I am lost on what else to do. Oil sensor disconnected and taped off because it turns on the oil light at times and kills spark, then smokes afterwards for a minute. Doesn't smoke with it unplugged. Probably irrelevant, but since I don't know, I am including it. Any help greatly appreciated. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-27-2020, 12:49 AM | #2 |
Not Yet Wild
Join Date: May 2019
Posts: 21
|
Re: 2005 carryall cafe express fe350 turns over sometimes also looking for cheap lift
Update, starter quit trying at all now. 12v one post, 5.5v other post, ground is good. Ordered a new one. Guess i will remove my new brushes for when I need them down the road.
|
06-30-2020, 08:58 PM | #3 |
Not Yet Wild
Join Date: May 2019
Posts: 21
|
Re: 2005 carryall cafe express fe350 turns over sometimes also looking for cheap lift
New starter installed, no more problems. Backfires at times tho.
|
07-01-2020, 08:25 AM | #4 |
Gone Wild
Join Date: Jul 2019
Location: Katy TX
Posts: 162
|
Re: 2005 carryall cafe express fe350 turns over sometimes also looking for cheap lift
I have a 05' Precedent and my oil light will come on at times but does not kill spark. I think you could have something else going on there.
|
07-03-2020, 07:53 PM | #5 |
Not Yet Wild
Join Date: May 2019
Posts: 21
|
Re: 2005 carryall cafe express fe350 turns over sometimes also looking for cheap lift
I bypassed the oil sensor since it was faulty and it killed spark constantly.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Cafe Express questions | Gas Club Car | |||
carryall 6 turns the breaks on by itself | Electric Club Car | |||
FE350 cheap on ebay | Gas Club Car | |||
2005 g22 yamaha wont go? solenoid turns off | Electric Yamaha |