|
Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
06-28-2014, 12:14 PM | #1 |
Getting Wild
Join Date: Jan 2011
Location: Dayton Ohio
Posts: 124
|
G14 Help needed Throttle values
I need the ohms readings and which wires to check. The controller is turning off when you suddenly push the pedal to the floor. Key off and back on Away you go.anyone know what ohms I should see .Throttle may be adjusted wrong. Thanks Rick
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-29-2014, 12:33 AM | #2 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: G14 Help needed Throttle values
White, blue, and green are the throttle wires. Throttle values are 0-1000 ohms for 36v yamahas with a controller.
|
06-29-2014, 10:01 AM | #3 |
Getting Wild
Join Date: Jan 2011
Location: Dayton Ohio
Posts: 124
|
Re: G14 Help needed Throttle values
Thanks for the reply.I checked with analog meter .[IIt showed 40 ohms at rest and 975 at full throttle with d.v.o.m. on 1000 scale it showed 41 ohms at rest and 984 at full throttle.That should not shut down the controller.as it is within range of yamahas specs.When the controller was rebuilt they said the the input regulator was out (a problem they don't often see.) Do you think they may have put in a wrong part? Do you know if that section of the controller is programmable by the rebuilder.As to the limit of ohms before shutdown occurs?If I just go 3/4 throttle up to speed and then floor it ,it goes fine. bUT IF I JUST FLOOR IT ,IT ROLLS OUT 10 FT OR SO AND QUITS.turn key off and right back on 1 time even before it comes to a stop and it will proceed..Do you know of anything but the controller that could be causing this ? The batts are new last fall.all wiring clean and tight nothing gets hot after heavy riding(motor warm=normal , controller warm=normal pack volts 40.5 I did notice it is worse when full charged,if that means anything.Also if it shuts down and you pedal up and down the sol is working and is powering up the large wires .Again key off key on (to reset the controller) and away we go. Any input from you is greatly appreciated. Thanks again Rick
[/I] |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Parts Wanted/Needed: Marathon Throttle Pivot Arm Assembly | Electric EZGO | |||
OHM's values please | Gas Yamaha | |||
Torque values | Gas Club Car | |||
needed diaghram of the throttle cable | Gas Yamaha | |||
Bolt Torque Values | Gas Yamaha |