lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 04-27-2013, 08:14 PM   #1
littlejohn444
Not Yet Wild
 
Join Date: Apr 2013
Posts: 23
Default How to test batteries?

Do I need to disconnect the leads from all the batteries?

It is a 36 volt system with 6 volt batteries. Do I need a tool other than a battery tester that can put a load on the battery and read the voltage?

If batteries test out what could cause the problem of being fully charged but the cart acts as if it has very little power? It will shudder a little taking off and then won't pull a hill.
littlejohn444 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 04-27-2013, 09:12 PM   #2
Kudaman
Gone Wild
 
Kudaman's Avatar
Club Car
 
Join Date: Mar 2013
Location: Ottawa, ontario, Canada
Posts: 292
Default Re: How to test batteries?

It's recommended to disconnect the batteries and test individually for the most accurate testing. You will likely find that your batteries are toast. They will hold a surface charge that can give you a good reading on a gauge however the battery doesn't have any life left in it.
Kudaman is offline   Reply With Quote
Old 04-28-2013, 04:57 AM   #3
JohnnieB
Techno-Nerd
 
JohnnieB's Avatar
E-Z-GO
 
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
Default Re: How to test batteries?

A digital voltmeter that will read the battery voltage with two digits to the right of the decimal point is needed. IE: A fully charged 6V battery should read 6.37V about 12 hours after the charger shuts off.

It is true that the cables should be disconnected for absolute measurements, but the parasitic load of keeping the filter capacitors in the controller precharged is very slight compared to the AH capacity of the batteries and they are connected in series, so the same current is passing through them equally and meaningful measurements can be made while the cables are connected.

Automotive type battery testers don't accurately test golf cart batteries because golf cart batteries are different animals than car batteries. They can be used, but you have to understand the differences between SLI (Starting - Lights -Ignition) batteries and Deep-Cycle batteries to interpret the results.


To test cart batteries:
Place on charger and let them charge until charger turns off automatically.
Wait about 12 hours or drive cart about 10 minutes and then wait 15 minutes.
Measure Pack voltage and individual battery voltages.
The pack voltage should be 38.7V. The individual battery voltages should be 6.37V and all withing 0.1V of each other.

Drive cart for about five miles or until it becomes sluggish, wait 15 minutes and measure voltages again.
How much the at-rest voltage has dropped depends of battery age, but they should still be within 0.1V of each other.
JohnnieB is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
How to test batteries Electric Club Car
How To Test Your Batteries Electric Club Car
how do i test my batteries? Electric EZGO
How to test the voltage of batteries?? Electric EZGO
Test charger with no batteries Electric EZGO


All times are GMT -5. The time now is 08:23 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2023, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.